Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Interior - Eliminating Unwanted Odors in Vehicles
- Body - Broken Rear Window Defogger Grid Detection
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Restraints - Seat Belt Latching Issues/Warning Lights
- A/C - Musty Odors Emitted From (HVAC) System
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Fuel System - Factors That Affect Economy/Mileage
- A/C - Erratic HVAC Operation & Self Diagnostic Blinks
- A/T - Loss of Drive or Erratic Shifts
- A/C Compressor - Moan Noise at 2100 RPM
- A/C - Odor at Start up in Humid Climates
- Engine - Oil Odors
- Exhaust - Squeak From Front of Vehicle
- Wheels - Plastic Wheel Nut Covers Loose/Missing
- Frame Insulator - Popping Noise Braking or Accelerating
- Seat Back, Second/Third Row - Difficult Locking Position
- Seats - Rattle From 2nd and 3rd Row Seats
- Brakes - ABS Light ON, DTC 46 & 86 (C1246 & C1286)
- A/C Control - Battery Runs Down/Loss of Control Settings
- Fuel Tank - Thud/Clunk Noise Between 3/4 and Full
- Fuel Gauge - Excessive During Quick Driving Maneuvers
- Headlamp Lens - Distortion Caused by Aiming Equipment
- Air Bag (SIR) On-Off Switch Kits, New Parts and Service
- Lift Gate Key Cylinder - Won't Return/Loose
- Liftgate - Loss of Locking Feature/Non-Power Locks
- Sliding Side Door - Rattles
- Power Sliding Side Door - Will Not Open
- Seat Belt Retractors, Front - Retract Slowly
- Seat Belts, Front - Slow to Return/Retract
- Door Glass, Front - Chatter or Scraping Noise
- Outside Rear View Mirror Glass - Vibration
- Luggage Rack - Wind Noise at Highway Speeds
- A/T - Garage Shift Engagement Delay
- Compact Disc Players - CD Changer Loading Procedures
- SIR - Operating Vehicle with Warning Light On
- Instrument Panel - Upper Surface Reflection
- Charging - Low Voltage Reading Or Dim Lights At Idle
- A/C - Temporary Loss of A/C in High Ambient Temperatures
- Engine - Hard Start or No Start
- Sliding Side Door - May Not Open in Cold Weather
- Steering Column - Intermittent Click Noise/Snap
- A/T - Harsh 1 to 2, 2 to 3, or 3 to 4 Upshifts
- Power Sliding Door - May Not Stay Open
- P/S - Reduced Assist When Cold
- Power Sliding Side Door - Loses Memory/Inoperative
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- Engine - Oil Leaks from Crankshaft Rear Main Seal
- Engine - Oil Leaks From Front Crankshaft Seal
- A/T - No Movement in Drive or 3rd Gear
- A/T - 4L60/65E, No Reverse/2nd or 4th Gear
- Body - Marks/Stains on Windshield When Wet
- Body - Bumps or Rust Colored Spots in Paint
- Body - Stain/Film On Windshield Glass Perimeter
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Labor/Parts Updates
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Interior - Eliminating Unwanted Odors in Vehicles
- Locks - Key Code Security Rules, Key Code Look Up
- Vehicle - Engine And Sub Systems Flushing Info. (CANADA)
- Vehicle - Engine And Sub-Systems Flushing Recommendations
- Wheels/Tires - Use Of Nitrogen Gas In Tires
- Tires - Information On Proper Tire Pressure
- Engine - THIS BULLETIN HAS BEEN CANCELED
- Fuel System - TOP TIER Detergent Gasoline
- Tires/Wheels - OE Tire Shake/Vibration Information
- Suspension - Shock Absorber/Strut Fluid Leak Information
- M/T - Operating Characteristics Information
- Brakes - Resurfacing Park Brake Portion of Rear Brake Rotor
- Body - Hem Flange Sealer For Corrosion Protection
- Engine - Intake Manifold Inspection/Replacement
- Body - Metal Body Panel Corrosion Protection
- Fuel System - GM Fuel System Treatment PLUS(R) Info.
- Body - Broken Rear Window Defogger Grid Detection
- Fuel System - Fuel Injector Maintenance Cleaning
- Audio - Inadvertent Steering Wheel Button Activation
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- A/T - Fluid Oil Cooler Flow Test
- Restraints - Child Seat Top Tether Attachment Kits
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Restraints - Passenger Presence System Information
- Lighting - Lamp Polycarbonate Lens Damage Prevention
- Restraints - Seat Belt Latching Issues/Warning Lights
- Body - Side Window Chipping Information
- Restraints - Driver/Passenger Seat Head Rest Information
- Engine - Use of 'Surface Conditioning Disks'
- Body - Application of Anti-Corrosion Materials
- A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
- A/C - Musty Odors Emitted From (HVAC) System
- A/T - Slight Vehicle Movement In Park At Start Up
- A/T - DEXRON(R)-VI Fluid Information
- Wheels/Tires - Refinishing Aluminum Wheels
- Lighting - Exterior Lamp Condensation and Replacement
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Steering/Suspension - Wheel Alignment Specifications
- Warranty - Claims Submission
- Warranty - Goodwrench Service Lifetime Service Guarantee
- Warranty - GM Dealer Parts Procurement
- Warranty - Labor Time Guide Updates, 09/99
- Warranty - Notice of Delayed Start Process
- Warranty - Parts Warranty Special Claims B and C
- Warranty - Labor Time Guide Update
- Warranty - Request for Wholesale Authorization
- Warranty Inquiry System
- Customer Concern Not Duplicated /Verified - Labor
- Warranty - Courtesy Transportation Guidelines
- VIN Plate - Replacement Policy and Procedure
- Warranty - GM Dealer Empowerment Program
- Labor - Revised Operation Z1241/Personal Property Damage
- Warranty - Repair/Replace Policies & Procedures
- Parts Expediting - Reimbursement Policy
- Warranty - Enhanced Sublet Repair Policy
- Warranty - Labor Time Guide Addition
- Warranty - Required Claim Submission Procedures
- Warranty - Repair and Claims Procedures
- Warranty - Corporate Parts Return Program Instructions
- Vehicle - Use of a Diagnostic Worksheet
- Vehicle - Squeak and Rattle Diagnostic Guide
- Roadside Assistance - Warranty Information
- Warranty Information Letters - Release Index
- Labor Time Guide - Format Change
- GM Campaign Identification Label
- ADCSM Empowerment Parameters - Retail Matrix
- Vehicle - AC Delco Locator Service, Electronics Exchange
- Electrical - Piercing Wire Insulation During Diagnosis
- Warranty - Diagnostic Claim Processing Revisions
- Campaign - Product Bulletin Numbering System
- Parts - Expediting Procedures
- Glass - Adhesive Caulking Kit Revisions
- Warranty - Corporate Parts Return Program
- I/M 240 Repairs - Obtaining Technical Assistance
- Fuel System - Factors That Affect Economy/Mileage
- Brake Fluid - Level And Filling Recommendations
- Warnings and Alarms, Chime - Revisions
- Electrical - Instrument Panel And General Wiring Repair
- A/C - Erratic HVAC Operation & Self Diagnostic Blinks
- HVAC System - Clarification of Content & Option Codes
- A/C Refrigerant - Contamination
- Tools - A/C Leak Detector Maintenance Kit Availability
- A/C - Systems With R12 Or R134a Service Issue
- A/C - Retrofitting R-12 to R-134a
- A/C - Tool And Equipment Maintenance
- A/C - PureGuard 2 Operating Alert
- A/C - System Sealers/Leak Detection Guidelines
- A/C - R-134a System Flushing Procedures
- Tools - Power Steering Bleeder Adapter
- A/T - Loss of Drive or Erratic Shifts
- ACDelco(R) Remanufactured Transmissions - Program Update
- PROM - Chuggle Above 36mph w/Torque Converter Engaged
- Engines - ACDelco Remanufactured
- Engine - Surface Conditioning Discs Precautions
- Engine - AC Delco Remanufactured Engines
- Steering - System Bleed Procedures
- A/C Compressor Seal Washer - Reference Chart
- A/C - Unnecessary Compressor Replacement
- A/C Compressor - Moan Noise at 2100 RPM
- A/C - Odor at Start up in Humid Climates
- Suspension - Shock Absorber/Strut Replacement Guidlines
- Tools - Adjuster Locknut Wrench
- Cooling - Radiator Repair/Replacement Guidelines
- Engine - Oil Odors
- Exhaust - Squeak From Front of Vehicle
- Steering Knuckle/Strut Assembly - Revised Torque Value
- Brake Pad/Caliper/Knuckle - Inspect & Maintenance
- Service Manual - Rear Shock Absorber Torque Revision
- Aluminum Wheels - Refinishing
- Warranty - Guidelines for Using E0420 Wheel Replace
- Warranty - OE Chrome Plated Aluminum Wheel ID
- Tires - Manufacturers' Assistance
- Tires - Speed Rated Information
- Wheels - Stud Removal Tool Change
- Wheels - Plastic Wheel Nut Covers Loose/Missing
- Frame Insulator - Popping Noise Braking or Accelerating
- Front Window Inoperative or Jumps When Rolled Up/Down
- Seat Back, Second/Third Row - Difficult Locking Position
- Seats - Rattle From 2nd and 3rd Row Seats
- A/T - Transaxle Oil Filter Differences
- A/T - Oil Cooler Flushing Frequently Asked Questions
- Recall 96V015001: A/T Oil Cooler Line Defect
- Recall 96V015000: A/T Fluid Cooler Line Defect
- Tools - Introduction Of The Fuel Injector Tester
- PROM - Reprogram Using Off Board Program Adapter
- Oxygen Sensors - Silica Contamination
- Front Wheel Bearing/Wheel Speed Sensor - New Design
- Brakes - ABS Light ON, DTC 46 & 86 (C1246 & C1286)
- Brakes - Wheel Cylinder Inspection Guidelines
- Battery - Diagnosis and Charging
- A/C Control - Battery Runs Down/Loss of Control Settings
- Updated Battery Replacement Catalog Numbers
- Warranty - New Vehicle/Replacement Battery
- Battery - Insulator Replacement & Caution
- Battery - Testing Equipment Explained
- Warranty - Improvements
- Battery - Parasitic Drain
- Tools - Released for CS Generator Diagnosis
- SPS/FLASH EPROM - Programming
- PROM - Powertrain Control Module Reprogramming
- Fuel Tank - Thud/Clunk Noise Between 3/4 and Full
- No MIL Diagnostic Chart A-1 Revision
- Audio - Procedure To Handle Customer Radio Concerns
- Radio Telephone/Mobile Radio - Install/Troubleshooting
- Air Bag - Module Shipping/Return Procedure
- Tools - SIR Driver/Passenger Load Tool and Adapter
- Air Bag - Load Tool and Adapter
- IP Dimmer Control - Proper Setting
- Parts - OE and Aftermarket Oil Filters Revised
- Oil Filters - Enhanced Anti-Drainback Valves
- Brakes - Rotor & Hub Flange Cleaning Tool Revision
- Campaign - Starter Motor Pinion Stop Collar Defects
- Fuel Gauge - Excessive During Quick Driving Maneuvers
- Odometer/Speedometer - ACDelco Service Center Locations
- Headlamp Lens - Distortion Caused by Aiming Equipment
- Anti-Lock Brake - Aftermarket Products Usage Precaution
- Brakes - Four Wheel Antilock Brake System Manual Update
- Antilock Brake/Traction Control - Wiring Diagrams Update
- Axle Control Arm Bolt, Rear - Torque Specification
- Roof - Vinyl Trim & Vinyl Top Repair
- Body - Sealer Tape For Collision Repairs
- Air Bag System - Diagnostic Chart B Updated
- SIR DTC 24 Diagnosis
- Air Bag Fuse - Location
- Air Bag Warning Lamp - Comes On Steady Chart Revised
- Air Bag (SIR) On-Off Switch Kits, New Parts and Service
- Airbags - Frontal (SIR) ON-Off Switch Kits, Parts/Procs
- Restraints - Air Bag System Diagnostics
- Security & Remote Keyless Entry System - Revision
- Lift Gate Key Cylinder - Won't Return/Loose
- Liftgate - Loss of Locking Feature/Non-Power Locks
- Warranty - Emission Parts Coverage
- Enhanced IM240 Program - Implementation Plan
- Emission - Enhanced Inspection Maintenance Programs
- I/M 240 Program - Equipment Purchase
- I/M Emissions Diagnostic Manual -Program
- Enhanced Emission I/M - Program Update
- Enhanced Emission Inspection Maintenance - Equipment
- Warranty - Guidelines for I/M 240 Labor
- Emissions Inspection/Maintenance - Labor Operations
- EVAP System - Service of Connectors
- Oxygen Sensor Test - Revised Tech 1 Mass Storage CD
- PCM - Returned Product Feedback Program
- Door Inner Panel - Repairs on SMC Type Doors
- Sliding Side Door - Rattles
- Power Sliding Side Door - Will Not Open
- Recall - Lap Belt Retractor Assembly Fails
- Seat Belt Retractors, Front - Retract Slowly
- Seat Belts, Front - Slow to Return/Retract
- Recall 94V015000: Seat Belt Retractor Defect
- Recall 93V212000: Seat Belt Defect
- Recall - Third Row Seat Belt Retractors Defective
- Child Restraint - Auxiliary Seat Belt
- Windshield - Two-Part Urethane Adhesive For Installation
- Warranty - Guidelines for Claiming Windshield Replace
- New Windshield/Glass Urethane Adhesive Caulking Kit
- Service Manual - Section 10-2 Update
- Door Glass, Front - Chatter or Scraping Noise
- Tools - Windshield Wiper Arm Removal
- Wiper Blade - Element Replacement
- Outside Rear View Mirror Glass - Vibration
- Luggage Rack - Wind Noise at Highway Speeds
- Coolant - Information on Propylene Glycol Usage
- Warranty - Recycled Engine Coolant Policy
- Engine Coolant - Information on Back Service
- Brake Pedal Replacement Procedure - Revised
- A/T - Forward and Reverse Servo Part Changes
- A/T - 4th Clutch & Hydraulic Updates
- A/T - Wiring Harness & Connector Pin Changes
- A/T - Garage Shift Engagement Delay
- A/T - Updated Shift Speed & Electrical Diagnosis Charts
- A/T - Revised Scavenger Oil Scoop
- A/T - New Drive Link Assembly and Drive/Driven Sprockets
- A/T - 4T60E Cold Start Rattle Noise
- A/T - New Solenoid Testing Kit
- A/T - Service Procedure Changes
- A/T - Core Return Product Feedback Form
- A/T - Diagnosing Fluid Leaks
- A/T - Torque Converter Identification
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - AXOD/E 44T4's and 125's Chain Stretch
- A/T - THM Late or No Upshifts
- A/T - 4T60E 3rd Sprag Clutch Replaces 3rd Roller Clutch
- A/T - 4T60E New Design Input Clutches
- A/T - Harsh Forward Engagement
- A/T - Rapid Converter Pump Bushing Wear
- A/T - 125, 200C/200 4R, 700 R4 Hidden Residue Build Up
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Compact Disc Players - CD Changer Loading Procedures
- Remote Keyless Entry Module - Revised Location
- SIR - Operating Vehicle with Warning Light On
- Exterior Lights - Revised Schematic, Component Location
- Crankcase Ventilation System - Revised Maintenance
- Engine - Serpentine Drive Belt Wear Information
- A/T - DEXRON III Fluid Introduction
- PROM/MEMCAL - Identification Marks
- Instrument Panel - Upper Surface Reflection
- Suspension - Chassis Lubrication Importance
- Engine - New Prelube Tool
- Charging - Low Voltage Reading Or Dim Lights At Idle
- Electrical - New Nickel Tape Shields Harnesses
- Cruise Control - (W/Electro Stepper Mtr.) Diagnostics
- Idle Speed - Specification Revised
- Engine - Hard Start Or No Start
- Tires/Wheels - Wheel Weight Usage Precautions
- Automatic Door Locks and Keyless Entry - Revisions
- Recall 94V100000: Shoulder Belt Defect
- Seat Belt System - Collision Replacement Guidelines
- Body - Urethane Adhesives for Glass Applications
- Key Code - Information
- Key/Key Number/Security Chip - Replacement
- Entertainment Systems - Correct Labor Codes
- Paint - Exterior Color Code & Cross Reference
- Paint - Polishing And Swirl Mark Removal
- Paint - Basecoat/Clearcoat Paint Systems Specifications
- Warranty - Rail Dust Removal & Chemical Spotting Labor
- A/C - Temporary Loss of A/C in High Ambient Temperatures
- Engine - Hard Start or No Start
- Sliding Side Door - May Not Open in Cold Weather
- Steering Column - Intermittent Click Noise/Snap
- A/T - Harsh 1 to 2, 2 to 3, or 3 to 4 Upshifts
- A/T - Revised Intermediate Band Friction Material
- Power Sliding Door - May Not Stay Open
- Tools - Keyless Entry Transmitter Tester
- A/C - Use of Alternate Refrigerants In CFC 12
- A/C - R134a Leak Detection With Tracer Dye
- Contaminated R12 Refrigerant - Testing & Handling
- A/C - R12 or R134a Service Recommendations
- A/C - Retrofitting R-12 Vehicles to R-134A
- A/C - Refrigerant Recovery/Recharge Equipment
- Wipers - Revised Cleaning Of Wiper Drive Shaft Knurls
- Sunshade - Replacement Availability
- P/S - Reduced Assist When Cold
- Fuel - Reformulated/Oxygenated Gasolines
- Fuel - Top Tier Detergent Gasoline Information
- A/C - New PAG Oil
- Doors - Power Sliding Side Door Parts Availability
- Power Sliding Side Door - Loses Memory/Inoperative
- Axle Oil Seal, Right - Leaks at the Axle Tripod Shank
- Body - Metal Panel Adhesive Bonding Information
- Cooling System - Coolant Recycling Information
- A/C - Contaminated R134A Refrigerant
- M/T - Hydraulic Clutch Bleeding Procedure Improvement
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- Instruments - Reduced PRNDL Display Visibility
- Body - Polypropylene Energy Absorber Replacement
- Engine - Sealant Usage/Procedures
- Engine - Oil Leaks from Crankshaft Rear Main Seal
- Electrical - Aftermarket Fuse Warning
- Engine - Oil Leaks From Front Crankshaft Seal
- Engine - Revised Cylinder Head Bolt Torque/Sequence
- Wheels - Chrome Wheel Brake Dust Accumulation/Pitting
- Electrical - Battery Charging Tips/Recommendations
- Restraints - Usage of Used/Salvaged/Imitation Components
- Fuel System - E85 Fuel Usage Precaution
- A/C - Refrigerant Recovery/Recycling/Equipment
- A/T - Torque Converter Replacement Information
- A/T - No Movement in Drive or 3rd Gear
- A/T - Grinding/Growling Noise in Park on Incline
- A/T - 4L60/65E, No Reverse/2nd or 4th Gear
- Engine/Fuel System - Oil/Fuel Additive Information
- Charging System - Low Voltage Display/Battery Discharged
- Cooling System, A/C - Aluminum Heater Cores/Radiators
- Wheels/Tires - Upsized Wheel/Tire Characteristics
- Audio System - Refurbishing Radio Faceplates/Knobs
- A/T Control - DTC P0756 Diagnostic Tips
- Body - Hem Flange Rust Repair Information
- Body - Marks/Stains on Windshield When Wet
- Wheels/Tires - Chrome/Steel Valve Stem Cap Precautions
- Body - Bumps or Rust Colored Spots in Paint
- Engine - Noise/Damage Oil Filter Application Importance
- Engine - Drive Belt Misalignment Diagnostics
- Body - Maintaining Exterior Weatherstrip Appearance
- 06-08-111-004B - BULLETIN CANCELLATION NOTIFICATION
- Body - Stain/Film On Windshield Glass Perimeter
- Wheels/Tires - Accessory Wheel And Tire Information
- Wheels/Tires - Replacement Wheel Weight Information
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Tires/Wheels - Tire Puncture Repair Procedures
- Lighting - Headlamp Warranty Replacement Guideline
- Mirrors - Heated Mirrors, Defrosting Time
- Interior - Proper Use of Floor Mats
- Wheels - Changing Procedures/Precautions
- Body - Squeeze Type Resistance Spot Welding/Equipment
- Restraints - Extender Availability For Seat Belt
- Interior - Seat Cover Wrinkle/Crease/Burn Info
- A/T - Water Or Coolant Contamination Information
- Body - Drilling High Strength Steel Using CryoCobalt(R)
- Body - Vehicle Glass Distortion Information
- Fuel System - TOP TIER Detergent Gasoline (Canada)
- Tires/Wheels - Information on Tire Radial Force Variation (RFV)
- Engine - GM Dexos 1(R) And 2(R) Oil Specifications
- Engine - GM dexos 1(R) and dexos 2(R) Oil Specifications/Info.
- Body - Pre-Painting/Cleaning Process For TPO Plastic Fascias
- Drivetrain - Information on Driveline Clunk Noise
- Wheels - Chromed Aluminum Wheel Staining/Pitting/Corrosion
- Body - Paint-less Dent Repair Process
- Wipers/Washers - Windshield Wiper Performance Information
- Electrical - Ground Repair Information
- Interior - Cleaning Instrument Panel, Interior Trim