Repair and Diagnosis: Technical Service Bulletins

• How to Find Technical Service Bulletins by Category/Symptom
• Recalls
  • Emissions
    • Recall - Engine Controller Replacement
      • Overview
      • Vehicle List
      • Parts
      • Owner Notification and Service Scheduling
      • Service Procedure
      • Completion Reporting and Reimbursement
      • Parts Return
      • Owner Letter
      • Dealer Service Instructions
  • Safety
    • Recall 92V017000: Disc Brake Lining Separation
    • Recall - Front and Rear Brake Linings
    • Recall - Rear Brake Linings
    • Recall 89V237000: Engine Valve Cover Gasket Oil Leak
    • Recall - Cylinder Head Cover Gasket Leaks
      • Overview
      • Vehicle List
      • Parts
      • Owner Notification and Service Scheduling
      • Service Procedure
      • Completion Reporting and Reimbursement
      • Parts Return
• Customer Interest
  • Fuel Pump - Filter Plugging
  • Rear Disc Brakes - Grinding Sound
  • Rear Brakes - Rattling While Driving
  • Engine - Valve Cover Oil Leak
  • Air Cleaner Housing - Has Oil Leaking From it
  • Exhaust Flex Joint - Squeaking
  • Exhaust System - Heat Melts Trunk Carpet
  • Rear Wheel Alignment - Uneven Tire Wear
  • A/T - Slips In Reverse At Low Temperature
  • Converter Lock Up Solenoid - Bucking/Surging
  • Throttle Body Wiring - MIL ON/DTC 25 Set
  • Air Cleaner Housing - Oil Leaking Form Housing
  • Wastegate Solenoid - Low Power At Full Throttle
  • Wastegate Solenoid - Momentary Loss of Engine Power
  • EGR Valve - Intermittent Rough Running At Idle
  • A/T - A604 Excessive Upshifting/Downshifting
  • Speedometer/Cruise Control - Fluctuates/Disengages
  • Black Plastic Body Components - Chalky Residue
  • MAP Sensor - MIL ON/DTC's 13/14 Set
  • Wiper Arm - Loose
  • Wipers/Washers - Wipers Smear or Streak Windshield
  • Windshield Washer Nozzle - Freezes Up
  • Lower Body Side Molding Insert - Loose
  • Convertible Top - High Latching Effort
  • A/T - A604 1-2 Gear Upshift Shudder
  • A/T - A604 Transfer Gear Whine Noise
  • A/T Transfer Gear - Whine or Whistle Type Noise
  • Alternator Belt - Noise Caused By Pulley Misalignment
  • Alternator Belt - Chirping/Snapping Noise
  • A/C, Heater Check Valve - Freeze-Up
  • Power Steering Gear - `Hissing' Noise
  • Convertible Top Boot Cover - Metal Clips Missing
  • Convertible Top - Hole/Slice in C Pillar Area
  • Headphones - Garbled Sound
  • MAP Sensor - DTC's 13 or 14 Set
• Superceded Bulletins
  • 240195 - 03/03/95
  • 210990 - 03/12/90
  • 110190 - 11/19/90
  • 07031 08/26/91
  • 070293 - 09/03/93
  • 070290 - 09/24/90
  • Cruise Control - Erratic During Initial Speed Set
  • Radio Transmitter Equipment - Installation
  • Radio Transmitting Equipment - Installation
  • Electrical - Wire Splice Procedure Revision
  • A/T - Vehicle Shudder During Torque Converter Operation
  • TCM - 41TE or 42LE A/T, Poor Shift Quality/Shudder
  • A/T - Fluid Usage
  • Engine Coolant - Recommendations
  • Alternator Belt - Snapping/Chirping Noise
  • A/T - ATF Usage List
• All Technical Service Bulletins
  • Body/Frame - Welded Sheet Metal Repairs And Replacements
  • Body - Don't Apply Corrosion Protection On Plastic Panels
  • Body - Front Bumper Fascia Repair For License Bracket Holes
  • Collision - Safety Cert./Tire Press. Label Replacement
  • Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
  • Wheels - Reconditioned Wheel Usage
  • Restraints - Replacement Seat Covers/Seat Cover Repairs
  • Restraints - Use Of Salvaged Restraint System Components
  • Body/Frame - Structural Repair Components
  • Body/Frame - Usage Of Heat For Repair
  • Vehicle Identification Number - Decoder
    • Overview
    • VIN Domestic Passenger Car
    • VIN Domestic Truck, Van/Wagon, Mpv
    • VIN MMC Import Vehicles
    • VIN Chrysler's Tc
  • Technical Service Bulletins - Body Code Usage
  • Instrument Cluster - Integrated Bulb Assembly
  • A/C - R-12 to R-134a Conversion Procedure
    • Overview
    • Introduction and Models Applicable
    • Procedures
      • A. Initial System Operation and Preparation
      • B. Conversion Procedure
      • C. Performance Test Procedure
    • R-134A Adaptation Component Chart
      • Passenger Cars
      • Minivans
      • Trucks
      • Jeeps
  • Flooded Engine - Service Precautions
  • Turbo I Diagnosis - Manual Update, TPS Volts High
  • EFI Diagnosis - Manual Revision, TPS Volts High
  • Power Steering Pump - Production Change
  • Fuel Pump and Filter - Replacement Information
  • Fuel Pump - Filter Plugging
  • Recall 92V017000: Disc Brake Lining Separation
  • Rear Disc Brakes - Grinding Sound
  • Rear Brakes - Rattling While Driving
  • Recall - Front and Rear Brake Linings
  • Recall - Rear Brake Linings
  • A/C Compressor - Revised Parts
  • Engine - Valve Cover Oil Leak
  • Recall 89V237000: Engine Valve Cover Gasket Oil Leak
  • Air Cleaner Housing - Has Oil Leaking From it
  • Exhaust Flex Joint - Squeaking
  • Exhaust System - Heat Melts Trunk Carpet
  • Rear Wheel Alignment - Uneven Tire Wear
  • Upholstery - Cleaning Procedure
  • Front Seat Recliner Lever - Location Revision
  • A/T - Slips In Reverse At Low Temperature
  • Converter Lock Up Solenoid - Bucking/Surging
  • A-604 A/T Oil Cooler - Flushing and Flow Testing
    • Overview
    • Discussion
    • Tools and Material Required to Flush System
    • Parts Required
    • Flushing Procedure
    • Flushing Procedure For Trailer Tow Package
    • Flow Testing Procedure
    • Warranty and Labor Info.
  • Clutch Splines and Pilot Bushing - Lubrication
  • Recall - Engine Controller Replacement
    • Overview
    • Vehicle List
    • Parts
    • Owner Notification and Service Scheduling
    • Service Procedure
    • Completion Reporting and Reimbursement
    • Parts Return
    • Owner Letter
    • Dealer Service Instructions
  • Throttle Body Wiring - MIL ON/DTC 25 Set
  • Air Cleaner Housing - Oil Leaking Form Housing
  • Wastegate Solenoid - Low Power At Full Throttle
  • Wastegate Solenoid - Momentary Loss of Engine Power
  • EGR Valve - Intermittent Rough Running At Idle
  • Fuel Injection Manual - EGR Diagnosis, Revision
  • A/T - A604 Excessive Upshifting/Downshifting
  • Radio Communication Equipment - Recommendations
    • Overview
    • Installation Recommendations
  • Rear Seat Shoulder Belt - Kit Availability
  • Airbag/Clock Spring - Service
  • Turn Signal Switch - Canceling Pin Indexing
  • Diagnostic Procedure - Manual Revision
  • Diagnostic Procedure - Manual Revisions
  • Temperature Gauge - Fluctuation Explanation
  • Speedometer/Cruise Control - Fluctuates/Disengages
  • Recall - Cylinder Head Cover Gasket Leaks
    • Overview
    • Vehicle List
    • Parts
    • Owner Notification and Service Scheduling
    • Service Procedure
    • Completion Reporting and Reimbursement
    • Parts Return
  • Black Plastic Body Components - Chalky Residue
  • Radio Transmitters - Installation
  • Air Bag - Service Manual Revisions
    • Overview
    • Test 1 (Book No. 81-699-8035)
    • Test 3 (Book No. 81-699-8035)
    • Test 17 (Book No. 81-699-8035)
    • Test 1 (Book No. 81-699-0012)
    • Test 3 (Book No. 81-699-0012)
    • Test 17 (Book No. 81-699-0012)
  • Passive Restraint - Diagnostic Procedure Revision
    • Overview
    • Test 4 1989 Passive Restraint System
    • Test 9 1989 Passive Restraint System
  • Airbag - Suspected Fault Diagnosis
  • Airbag - NHTSA Authorized Deactivation
    • Overview
    • Instruction Sheet K6855297
    • Drivers Side Airbag -- '95- '96 XJ Only
    • Passenger Side Airbag -- All
    • Both Airbags -- All
  • MAP Sensor - MIL ON/DTC's 13/14 Set
  • Fault Code - Updated Diagnostic Terminology
    • Overview
    • 14-56 Multi-Point Fuel Injection
    • 14-30 Single Point Fuel Injection
    • 14-84 Multi-Point Fuel Injection
  • Auto Computers - Y2K Effects
  • Wiper Arm - Loose
  • Wipers/Washers - Wipers Smear or Streak Windshield
  • Windshield Washer Nozzle - Freezes Up
  • Lower Body Side Molding Insert - Loose
  • Engine Oil - New `SG' Level Oil
  • Engine Coolant - Recycling Recommendations
  • Engine - Coolant Recommendations
  • Convertible Top - High Latching Effort
  • Power Steering Hose - Replacement Procedure
  • A-604 A/T - Clutch Slippage or Shift Bump
    • Overview
    • Discussion
    • Diagnosis/Inspection
    • Transaxle Reconditioning Reminders
  • A/T - A604 1-2 Gear Upshift Shudder
  • A/T - Clutch Volume Index QuIck Learn
  • Automatic Transmission - Gear Selection Revised
  • A/T - A604 Transfer Gear Whine Noise
  • A/T Transfer Gear - Whine or Whistle Type Noise
  • A/T - Engine Vacuum Testing
  • A/T - How To Use A Pressure Gauge
  • A/T - Intermittent Electrical Problems
  • A/T - Failsafe Modes
  • A/T - Slipping or No-Shift/Metal Sealing Rings
  • A/T - Front Bushing Wear
  • A/T - Math Formulas Part I
    • Overview
    • Shift Speed and Pressure
    • Speedometer Ratios
  • A/T - Twenty Steps To Successful Repairs
  • A/T - Math Part II
  • A/T - Choosing the Right ATF
  • Campaign - Flywheel Attachment Bolts
  • EGR Valve - Diagnostic Procedures Revision
  • Engine Mounting - Service Manual Revision
  • Alternator Belt - Noise Caused By Pulley Misalignment
  • Alternator Belt - Chirping/Snapping Noise
  • A/T - ATF+4 Fluid Usage/Applications
  • A/C, Heater Check Valve - Freeze-Up
  • Power Steering Gear - `Hissing' Noise
  • Engine - Oil Leak Diagnosis
  • Wiring - Revised Splicing Procedure
  • Wiring - Repair Instruction Sheets
  • Electrical Connectors - Cleaning Precautions
  • Minimum Idle Air Flow - Manual Revisions
    • Overview
    • Front-Wheel-Drive Car Service Manual #81-270-9003
    • Spirit and Acclaim Service Manual #81-270-9025
    • Front-Wheel-Drive Van Service Manual #81-370-9005
    • Chrysler's Tc (Maserati) Service Manual #81-270-9050
    • 1989 2.5L Turbo I
    • 1988 2.2L Turbo and Turbo II
  • Speed Control - Adaptive Strategy
  • Convertible Top Boot Cover - Metal Clips Missing
  • Convertible Top - Hole/Slice in C Pillar Area
  • Passive Restraint - Diagnostic Procedures, Revision
  • Headphones - Garbled Sound
  • Stone Guard - Paint Repair
  • Paint - Codes/Applications/Cross References
    • Overview
    • 1989 Chrysler-Plymouth-Dodge Domestic Passenger Car Exterior Paint
    • 1989 Chrysler-Plymouth-Dodge Domestic Passenger Car Interior Paint
    • 1989 Chrysler-Plymouth-Dodge Domestic Passenger Car Interior Two-Tone Paint
    • 1989 Chrysler-Plymouth-Dodge Passenger Car Vinyl Roof
    • 1989 Chrysler-Plymouth-Dodge Striping Lacquers
    • 1989 Chrysler-Plymouth-Dodge Passenger Car Low Lustre Accent Colors and Bumper Facia
    • 1989 Dodge Truck Exterior Paint
    • 1989 Dodge Colt/Eagle Summit Passenger-Car Exterior Paint
    • 1989 Chrysler-Plymouth-Dodge Passenger Car Exterior Paint - Imports From MMC Except Colt/Summit
    • 1989 Chrysler-Plymouth-Dodge Underhood Paint - All Imports From MMC
    • 1989 Jeep Exterior Paint
    • 1989 Jeep Interior Paint
    • 1989 Eagle Premier Passenger Car Exterior Paint
    • 1989 Eagle Medallion Passenger Car Exterior Paint
    • 1989 Chrysler Maserati T/C Passenger Car Exterior Paint
    • Paint Suppliers/Codes By Assembly Plant
  • Paint - Variance Program
  • Front Shock Tower - Metal Screws/Bolts Precautions
  • Electronic Traveler - Self Diagnostics Revision
  • A/C Refrigerant - Substitutes and Compatibility
  • Power Steering Fluid - Specifications
  • Child Seat Anchor - Installation
    • Overview
    • Pkg. No. 4519077
    • Pkg. No. 4519071
    • Pkg. No. 4358469
    • Pkg. No. 4519072
    • Pkg. No. 4519073
    • Pkg. No. 4519074
    • Pkg. No. 4519075
    • Pkg. No. 4519076
    • Pkg. No. 4519080
    • Pkg. No. 4519081
    • Pkg. No. 4519082
    • Pkg. No. 4519292
  • MAP Sensor - DTC's 13 or 14 Set
  • A/T Pan Gasket - Reusable Design/Installation
    • Overview
    • Installation Procedure
  • A/T - ATF + 4 Fluid Usage
  • Body - Paint Overspray Removal Procedures
  • Paint - Clearcoat Blending During Refinish Process