Electrical - MIL ON/Multiple DTC's Stored In Memory
TSB 10-15-108/16/10
P07XX, P0642, P0138, P0141, P0219 AND/OR
ERRATIC SHIFTING AND/OR ERRATIC
SPEEDOMETER - BUILT ON OR BEFORE 12/29/2009
FORD:
2010 Transit Connect
ISSUE
Some 2010 Transit Connect vehicles built on or before 12/29/2009 may exhibit a malfunction indicator light (MIL) on with or without diagnostic trouble codes (DTCs) PO7XX, P0642, P0138, P0141, P0219 and/or erratic transmission shifting and/or erratic speedometer. The customer may report that the condition occurs only when the vehicle is in reverse. The condition may be related to the increase in engine roll when the vehicle is in reverse.
ACTION
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
1. Remove the powertrain control module (PCM). Refer to Workshop Manual (WSM), Section 303-14.
2. Remove the battery tray. Refer to WSM, Section 414-04.
3. Inspect the wiring from C175T for possible chafing, especially when the vehicle is placed in reverse. Engine roll may cause this harness to chafe against the thermostat housing hose clamp. (Figure 1)
4. Repair any chafed wiring as necessary.
5. Reposition the wiring harness away from the thermostat housing hose clamp and tie strap (obtained locally) to the battery hold down screw.
6. Reinstall the battery tray. Refer to WSM, Section 414-04.
7. Reinstall the PCM. Refer to WSM, Section 303-14.
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION DESCRIPTION TIME
MT01501 Claim Diagnosis And Labor Actual
Performed As Actual Time Time
DEALER CODING
CONDITION
BASIC PART NO. CODE
12B637 30
Disclaimer