Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Brakes - Grinding/Pulling/Uneven Wear
- Brakes - Clicking Noise Upon Application
- Brakes - Excessive Brake Dust on Wheels
- A/C Compressor - Engine Hesitation or Surge
- Engine - MIL ON/Variable Cam Timing DTC's Set
- Side Doors - Wind Noises
- Engine - Vibration While Idling
- Engine - Lean Driveability Symptoms
- PCM - Spark Knock on Light Acceleration
- Engine - Stall After Cold Start and Transaxle Engagement
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Engine - MIL ON/DTC's Set/ Rough Idle/Stall
- Windshield - Water Leaks
- VCT Solenoid - MIL ON/Trouble Codes Stored
- Paint - Rough Texture
- A/T - Inadvertent Shift Interlock Disabling
- Chemicals,Additives
- Factory Modifications
- Seals, Gaskets
- Superceded Bulletins
- 99-10-5 - 06/28/99
- Rear Window Defroster - Inoperative
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Electrical - Wiring Soldering/Crimping Tips
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Battery - Service/Charging Tips
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Brake Shift Interlock - Inadvertent Disabling
- Vehicle - Calibration Information
- Speakers - Whining/Buzzing Noise
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- EVAP - MIL ON/DTC's P0442/P0455/No Driveability Concerns
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - Out Of Vehicle Reprogramming
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Engine - Idle Vibration
- Engine Crossmember/Mount - Idle Vibration
- Battery - Battery EYE Function/Charging Service Tips
- Engine - Rough Idle/Low Power/Stall/DTC's/MIL ON
- All Technical Service Bulletins
- A/C System - Diagnosis and Service Tips
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Electrical - New Terminal Grease Released For Service
- Brakes - Grinding/Pulling/Uneven Wear
- Brakes - Clicking Noise Upon Application
- Brakes - Excessive Brake Dust on Wheels
- A/C Compressor - Engine Hesitation or Surge
- Engine - MIL ON/Variable Cam Timing DTC's Set
- Timing Belt/Tensioner - Revised Setup Procedure
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Wheels/Tires - Road Force Measurement Equipment
- Side Doors - Wind Noises
- Engine - Vibration While Idling
- A/T - Cooler Flushing Service Tips
- PCM - Reprogramming Out of Vehicle
- Engine - Lean Driveability Symptoms
- PCM - Spark Knock on Light Acceleration
- Engine - Stall After Cold Start and Transaxle Engagement
- Engine Controls - General PCM Programming Procedures
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Campaign - Headlamp Dust Cap Replacement
- Engine Head Gasket - Approved Replacement Procedures
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Engine - MIL ON/DTC's Set/ Rough Idle/Stall
- PCM - Calibration Information
- Interior Door Trim Panel - Replacement Tip
- Windshield - Water Leaks
- VCT Solenoid - MIL ON/Trouble Codes Stored
- Motor Oil - Viscosity Grade Recommendation
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - Transmission Flush and Fill Tool Available
- Recall 99V276000: Incorrect Shift Pattern
- Recall - M/T Shift Pattern Placard Missing
- A/T - Mercon V ATF Usage
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Keyless Entry System - Service Tips
- Interior Trim - Vinyl Surface Repair Tips
- Paint - Rough Texture
- A/T - Inadvertent Shift Interlock Disabling
- A/C - Identification of Non Approved Refrigerants
- Brakes - Vibration/Inspection Service Tips
- Fuel - Volatility Related Driveability Concerns
- Vehicle - Towing Behind Recreational Vehicles
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Battery - Battery Eye Function/Charging/Service
- Comprehensive Noise/Vibration/Harshness Procedure
- Overview
- Description and Operation
- Diagnosis and Testing
- Overview
- Diagnostic Process
- 1. Customer Interview
- 2. Pre-Drive Check
- 3. Preparing For the Road Test
- 4. Verify the Customer Concern
- 5. Road Test
- 6. Check OASIS/TSBs/Repair History
- 7. Diagnostic Procedure
- NVH Condition and Symptom Categories
- Symptom Charts
- Pinpoint Tests
- Overview
- Pinpoint Test A: Brake Vibration/Shudder Diagnosis
- Pinpoint Test B: Engine Ticking Noise Diagnosis
- Pinpoint Test C:Front ENG. ACC. Drive (Fead) Bearing Hoot Diag.
- Pinpoint Test D: Power Steering Moan Diagnosis
- Pinpoint Test E: Engine Driven Cooling Fan Moan Diagnosis
- Pinpoint Test F: Drumming Noise Diagnosis
- Pinpoint Test G: Engine Ticking, Knock/Continuous Rattle Diag.
- Pinpoint Test H: Front Suspension Noise Diagnosis
- Pinpoint Test I: Rear Suspension Noise Diagnosis
- Pinpoint Test J: Wheel and Tire Diagnosis
- Pinpoint Test K: High Speed Shake or Shimmy Diagnosis
- Pinpoint Test L: Clutch Vibration
- Pinpoint Test M: Transfer Case Vibration
- Component Tests
- Tire Wear Patterns & Frequency Calculations
- General Procedures