Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 00V349000: Hood Striker Fracture/Failure
- Recall - Safety Belt Retractor Inspection/Replacement
- Recall 99V250000: Seat Belt Retractor Defect
- Recall 99V062001: Cruise Control Cables, Binding
- Recall - Speed Control Cable Replacement
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Question and Answer Sheet
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Owner Letter
- Recall 99V062000: Sticking Cruise Control Cable
- Recall - Park Brake Control Modification
- Overview
- Dealer Letter - October 2000
- Dealer Letter - November 2000
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Example Mustang Owner Guide
- Owner Letter
- Supplement #1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Attachment IV
- Supplement # 1 - Owner Letter
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- A/T Cooler - Fluid Leaks at Radiator
- Exhaust System - Leaks/Noise
- Driveline - Whining Noise On Coastdown
- M/T - Hard To Shift Into 1st or Reverse When Stopped
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Engine - Lean Driveability Symptoms
- Body - Road Noise/Dust/Water in Luggage Compartment
- Left Hand Rear Quarter Area - Creaking Noise
- Driver's Footwell Area - Popping/Oil Canning Noise
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
- A/T - 4R70W TCIL/MIL ON/Trouble Codes Stored
- Hood - Difficult to Close
- Windshield Wipers - Operate While Switch is OFF
- Interior - Passenger Seat Squeaking Sound
- Hood Scoop - Loose or Detached
- Windshield - Water Leaks
- Cup Holder - Not Deep Enough to Hold Large Cups
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Convertible Top Boot - Improper Fit
- Paint - Rough Texture
- A/T - Inadvertent Shift Interlock Disabling
- A/T - 4R70W Clunk Noise on 2nd to 1st Gear Downshift
- M/T - T45 Stuck In Reverse/Pops Out Of Reverse
- A/C - Heater Core Electrolysis/Leakage
- Chemicals,Additives
- Factory Modifications
- Seals, Gaskets
- Superceded Bulletins
- Rear Window Defroster - Inoperative
- Front Wipers - Operate While Switch is in OFF Position
- Front Wipers - Operate While Switch Is In Off Position
- Passive Antitheft System (PATS) - Diagnostics Tips
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- A/T - 4R70W Delayed Or No 2-3 Upshift
- Electrical - Wiring Soldering/Crimping Tips
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Passive Antitheft System - Diagnostic Service Tip
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Rear Suspension - Whine Noise When Coasting
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Brake Shift Interlock - Inadvertent Disabling
- A/T - Fluid Leak At Radiator Oil Cooler
- Vehicle - Calibration Information
- Speakers - Whining/Buzzing Noise
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- A/T - 4R70W MIL/TCIL ON/Trouble Codes Stored
- EVAP - MIL ON/DTC's P0442/P0455/No Driveability Concerns
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - DTC's P1635 or P1639 Set/4X4 Lamp ON
- PCM - Out Of Vehicle Reprogramming
- Exhaust System - Leaks From R/H Exhaust Pipe
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Engine - Oil Recommendations/Applications
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- All Technical Service Bulletins
- A/C System - Diagnosis and Service Tips
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Electrical - New Terminal Grease Released For Service
- Fuel Pump - Whine Heard Through Radio Speakers
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- A/T Cooler - Fluid Leaks at Radiator
- Exhaust System - Leaks/Noise
- Wheels/Tires - Road Force Measurement Equipment
- Driveline - Whining Noise On Coastdown
- A/T - Cooler Flushing Service Tips
- Clutch Pedal - Vibration Heard or Felt
- M/T - Hard To Shift Into 1st or Reverse When Stopped
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- PCM - Reprogramming Out of Vehicle
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions/Engine Controls - Driveability Diagnosis
- Engine - Lean Driveability Symptoms
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine Controls - General PCM Programming Procedures
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Engine Head Gasket - Approved Replacement Procedures
- Body - Road Noise/Dust/Water in Luggage Compartment
- Left Hand Rear Quarter Area - Creaking Noise
- Driver's Footwell Area - Popping/Oil Canning Noise
- PATS System - Diagnostic Service Tips
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- PCM - Calibration Information
- A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
- A/T - 4R70W TCIL/MIL ON/Trouble Codes Stored
- Hood - Difficult to Close
- Recall 00V349000: Hood Striker Fracture/Failure
- Windshield Wipers - Operate While Switch is OFF
- Interior Door Trim Panel - Replacement Tip
- Interior - Passenger Seat Squeaking Sound
- Hood Scoop - Loose or Detached
- Recall - Safety Belt Retractor Inspection/Replacement
- Recall 99V250000: Seat Belt Retractor Defect
- Windshield - Water Leaks
- Body - Exterior Mirror Glass/Motor Service Tips
- Cup Holder - Not Deep Enough to Hold Large Cups
- Motor Oil - Viscosity Grade Recommendation
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - Cold Fluid Level Checking
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- Recall 99V062001: Cruise Control Cables, Binding
- Recall - Speed Control Cable Replacement
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Question and Answer Sheet
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Owner Letter
- Recall 99V062000: Sticking Cruise Control Cable
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Convertible Top Boot - Improper Fit
- Keyless Entry System - Service Tips
- Interior Trim - Vinyl Surface Repair Tips
- Locks - Lock Service Packages Available
- Paint - Rough Texture
- A/T - Inadvertent Shift Interlock Disabling
- A/C - Identification of Non Approved Refrigerants
- A/T - 4R70W Clunk Noise on 2nd to 1st Gear Downshift
- M/T - T45 Stuck In Reverse/Pops Out Of Reverse
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Brakes - Vibration/Inspection Service Tips
- Recall - Park Brake Control Modification
- Overview
- Dealer Letter - October 2000
- Dealer Letter - November 2000
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Example Mustang Owner Guide
- Owner Letter
- Supplement #1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Attachment IV
- Supplement # 1 - Owner Letter
- Fuel - Volatility Related Driveability Concerns
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Comprehensive Noise/Vibration/Harshness Procedure
- Overview
- Description and Operation
- Diagnosis and Testing
- Overview
- Diagnostic Process
- 1. Customer Interview
- 2. Pre-Drive Check
- 3. Preparing For the Road Test
- 4. Verify the Customer Concern
- 5. Road Test
- 6. Check OASIS/TSBs/Repair History
- 7. Diagnostic Procedure
- NVH Condition and Symptom Categories
- Symptom Charts
- Pinpoint Tests
- Overview
- Pinpoint Test A: Brake Vibration/Shudder Diagnosis
- Pinpoint Test B: Engine Ticking Noise Diagnosis
- Pinpoint Test C:Front ENG. ACC. Drive (Fead) Bearing Hoot Diag.
- Pinpoint Test D: Power Steering Moan Diagnosis
- Pinpoint Test E: Engine Driven Cooling Fan Moan Diagnosis
- Pinpoint Test F: Drumming Noise Diagnosis
- Pinpoint Test G: Engine Ticking, Knock/Continuous Rattle Diag.
- Pinpoint Test H: Front Suspension Noise Diagnosis
- Pinpoint Test I: Rear Suspension Noise Diagnosis
- Pinpoint Test J: Wheel and Tire Diagnosis
- Pinpoint Test K: High Speed Shake or Shimmy Diagnosis
- Pinpoint Test L: Clutch Vibration
- Pinpoint Test M: Transfer Case Vibration
- Component Tests
- Tire Wear Patterns & Frequency Calculations
- General Procedures