Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - White Flakes/Powder Blow From Dash Vents
- Engine - Vibration At Idle
- Engine Controls - Hard Start/Long Crank Time
- A/C - Compressor Leaking/Inoperative
- M/T - Clunking/Rattling Noise/Premature Clutch Wear
- Engine Controls - Rattle From PCM/ECM Bracket
- Brakes - Rear Drum Brake Squealing Noises
- Battery - Clunk Noise On Turns/Battery Sliding in Tray
- Engine Controls - MIL ON/DTC P2004 Set
- Engine Controls - No Crank/DTC B1601/PATS Issues
- Engine Controls - Long Cranking Time/Hard Start
- Wipers/Washers - Loss of Intermittent or Park Functions
- Body, A/C - Water Leaks to Vehicle Interior
- Body - Luggage Compartment Open With Remote
- Body - Trunk Lid Contacts Bumper Cover
- Wheels - 9 Spoke Wheel Cover Squeaking Noises
- Interior - Carpet Pulling Away From R/H Kick Panel
- Audio System - CD Player Skips/Locks-Up/Inoperative
- M/T - Hard to Shift Gears
- M/T - Difficult or Unable to Shift Into 5th Gear
- M/T - Shift Cable Detach From Transaxle
- Ignition System - Cannot Remove/Turn Key/Chime ON
- Body - Power Door Locks Cycling/Self-Locking
- A/C - Heater Core Electrolysis/Leakage
- Brakes/Engine Controls - High Pedal Effort at High Alt.
- Audio System - CD Player pauses/Skips Between Tracks
- Interior - Carpet Pulling Out From Under Scuff Plate
- Interior - Head Rests Rise While Driving
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Interior - Console Arm Rest Pivot Loose
- Brakes - Rear Drum Brake Squealing Noise
- Fuel - Fuel Fill Slow Or Early Shut Off
- M/T - Clutch Pedal Squeaks/Excessive Free Play
- Factory Modifications
- Superceded Bulletins
- 07-12-4 -06/25/07
- 04L22 - 07/01/04
- Interior - Trim Paint Application Procedures
- Interior Carpet Pulling Out From Under Scuff Plates
- Audio System - CD Player Skipping/Locks Up/Inoperative
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Restraints - DTC And Associated Fault PID Service Tips
- A/C - White Flakes Blowing From Dash Vents
- A/C - White Flakes Are Blowing From Dash Vents
- A/C - White Flakes Come From Dash Vents With Blower ON
- A/C - White Flakes Blow From Dash Vents
- A/C - White Flakes From Vents With Blower ON
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wire Harness Replacement Service Tips
- Electrical - Wiring Harness Replacement Guidelines/Tips
- Battery - Service/Charging Tips
- Brakes - Rear Drum Brake Squealing Upon Application
- M/T - Clutch Pedal Squeak/Excessive Free Play
- Engine Controls/Brakes - High Altitude High Brake Effort
- Ignition - Key Hard to Turn/Remove from Ignition Lock
- Engine Controls - General PCM Reprogramming Procedures
- Engine - Excessive Vibration At Idle
- Engine - Vibrates At Idle
- Engine - Excessive Idle Vibration
- Engine - Vibrates at Idle
- Engine - Vibration At Idle
- Engine - Vibration at Idle
- Engine - Excessive Vibration at Idle
- Engine - Crankshaft Pulley Bolt Service Precaution
- Engine - Crankshaft Pulley Bolt Removal Precaution
- Battery - Battery EYE Function/Charging Service Tips
- Drivetrain - Neutral Towing Kit/Applications
- A/T, M/T - Vehicle Neutral Tow Capability/Service Kit
- Ignition System - Engine Misfire Diagnostics Tips
- All Technical Service Bulletins
- A/C - White Flakes/Powder Blow From Dash Vents
- Engine - Vibration At Idle
- Engine Controls - Hard Start/Long Crank Time
- A/C - Compressor Leaking/Inoperative
- Recall - Rear Door Latch Corrosion/Won't Latch Correctly
- M/T - Clunking/Rattling Noise/Premature Clutch Wear
- Engine Controls - Rattle From PCM/ECM Bracket
- Brakes - Rear Drum Brake Squealing Noises
- Battery - Clunk Noise On Turns/Battery Sliding in Tray
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine Controls - MIL ON/DTC P2004 Set
- Engine Controls - No Crank/DTC B1601/PATS Issues
- Engine Controls - General PCM Programming Procedures
- Engine Controls - Long Cranking Time/Hard Start
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Wipers/Washers - Loss of Intermittent or Park Functions
- Body - Weld Bonding Procedure
- Body, A/C - Water Leaks to Vehicle Interior
- Recall - VECI Label Replacement
- Body - Luggage Compartment Open With Remote
- Body - Trunk Lid Contacts Bumper Cover
- Wheels - 9 Spoke Wheel Cover Squeaking Noises
- Vehicle - Tow Capability/Service Kit Requirements
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostic Updates
- Interior - Repair/Paint to Match Instructions
- Interior - Carpet Pulling Away From R/H Kick Panel
- Audio System - CD Player Skips/Locks-Up/Inoperative
- Paint - Repair Due To Iron Particles/Acid Rain
- M/T - Hard to Shift Gears
- M/T - Difficult or Unable to Shift Into 5th Gear
- M/T - Shift Cable Detach From Transaxle
- Ignition System - Cannot Remove/Turn Key/Chime ON
- Body - Power Door Locks Cycling/Self-Locking
- A/C - Heater Core Electrolysis/Leakage
- Engine Crankshaft - Pulley Bolt Service Precautions
- Brakes/Engine Controls - High Pedal Effort at High Alt.
- Audio System - CD Player pauses/Skips Between Tracks
- Keyless Entry - Keypad Diagnostics
- Clutch - MTX-75 Premature Clutch Failure
- Interior - Carpet Pulling Out From Under Scuff Plate
- Interior - Head Rests Rise While Driving
- Steering - Mercon V(R) Fluid Usage
- Electrical - Wiring Harness Replacement Guidelines
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Interior - Console Arm Rest Pivot Loose
- Steering/Frame - Vehicle Pulling or Drifting
- Brakes - Rear Drum Brake Squealing Noise
- Restraints - Control Module DTCs, Associated Fault PIDs
- Fuel - Fuel Fill Slow Or Early Shut Off
- M/T - Clutch Pedal Squeaks/Excessive Free Play