Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Recall 99V069000: Lower Ball Joint Replacement
- Recall 02V120000: Ignition Switch Defect
- Recall - Ignition Switch Replacement
- Recall - Ignition Switch Key Interlock Defect
- Recall 97V220000: Seat Belt Retractor Defect
- Recall 97V220000: Seat Belt Anchor Defect
- Recall 98V018000: A/T Park Pawl Modification
- Recall 98V018000: Parking Pawl Modification
- Recall 03V423000: Ignition Cylinder Inspection/Repair
- Customer Interest
- Wheel Bearings, Rear - Noise
- Muffler Paint Peeling
- Engine Controls - MIL ON/DTC P0107or P0108 Set
- Accessory Trunk Spoiler - Damages Trunk Paint
- Rear Doors - Water Leaks To The interior
- Doors - Stick While Being Opened
- Moonroof Visor Seal - Splits
- Headliner/Windshield/Moonroof - Creaking/Popping
- Ceiling Light Area - Rattle
- Drivetrain - Clicking Noise On Low Speed Turns
- M/T - Clutch Pedal Noise
- Emissions/Engine Controls - MIL ON/DTC P1457 (EVAP)
- Brakes - ABS Wheel Sensor Harness Rubs on Wheel
- Brake System - Indicator Lamp Stays ON
- Brakes - Brake Indicator Comes ON/Goes OFF
- Emissions - MIL ON/DTC P0420 (Catalytic Converter) Set
- Emissions - MIL ON/DTC P0420 (Catalyst Efficiency)
- Security System - Activates When Not Armed
- Interior - Seat Belts Slow to Retract
- Fuel Gauge - Readings Are Inaccurate
- Suspension - Rattle From Rear Stabilizer Bar
- Rear Shelf Area - Creaking Noise
- Antitheft - Security System Will Not Function
- MIL ON - P0304 and/or P0306 Codes
- MIL ON - DTC P0401 EGR Flow Insufficient
- Instruments - Clock Light Inoperative
- Body - Wind Noise From the Top of the WIndshield
- Glove Box Door - Rattle
- M/T - Bangs in Reverse Gear
- Audio Unit with CD Player/Changer - Error Codes
- Trunk - Will Not Open With Remote Transmitter
- Power Windows/Door Locks - Do Not Work
- Ceiling Light - Flickers
- Audio System - Remote Controls Don't Work Properly
- Interior - Side-to-Side Looseness in Driver's Power Seat
- Antitheft System - Panic Alarm Sounds By Itself
- M/T - 5th Gear Grinds On Upshift
- Body - Moonroof Seal Squeaks
- Interior - Seat Back Panel Loose/Detached
- Suspension - Rear Stabilizer Link Broken
- Engine - Idle Vibration/Harsh Shifting
- Engine - Oil Leaks From Front/Middle/Rear of Engine
- Body - Windshield Moulding Warped/Deformed
- Steering/Suspension - Vehicle Pulls Left/Right
- Recommended Repairs
- Safety
- Superceded Bulletins
- 90-011 - 05/02/09
- 89-022 - 06/18/04
- 99-018 - 04/20/06
- 02-025 - 11/12/2002
- 98-019 - 05/13/05
- 06-001 - 01/16/06
- 99-085 - 12/16/99
- 99-075 - 08/24/99
- 99-040 - 05/25/99
- 99-039 - 05/13/99
- 99-023 - 03/09/99
- 99-018 - 04/20/99
- 98-084 - 10/07/03
- 98-045 - 06/09/98
- 98-011 - 02/05/02
- 97-015 - 08/31/99
- 95-057 - 10/17/00
- 90-014 - 12/15/97
- 89-029 - 05/06/96
- 86-020 - 06/08/99
- 03/088 - 01/08/04
- 03-078 - 10/17/03
- 02-031 - 09/17/02
- 02-010 - 03/19/02
- 01-029 - 03/20/01
- 01-023 - 09/01/02
- 01-009 - 01/16/01
- 01-003 - 01/16/01
- 00-088 - 04/03/01
- 00-088 - 08/14/02
- 00-018 - 02/15/00
- 00-017 - 07/17/00
- Required Special Tools And Equipment,
- Recommended Materials
- Service Publications and Supplies - Ordering Information
- Windshield Molding - Warped/Deformed
- Body - Recommended Repair Materials
- Body - Recommended Sealers And Adhesives
- Body - Recommended Sealers/Repair materials
- Campaign - Seat Linkage Inspection/Modification
- Campaign - Seat Track Linkage Replacement
- Moonroof - Squeak Noise With Sunshade Open
- Paint - Codes And Cross references
- Body - Deformed Windshield Moulding
- Body - Deformed Windshield Molding
- Body - Windshield Molding is Deformed
- Body - Windshield Molding Deformed
- Body - Windshield Moulding is Deformed or Warped
- Audio Unit - Warranty Exhange/Out of Warranty Repair
- Audio Unit - Warranty Exchange/Customer Pay Repair
- Radio - Audio Unit Error Code
- Audio/Navigation/RES - Warr. Exchange/Non-Warr. Repair
- Audio/Navigation/RES Unit - Warranty Exchange/Repair
- Audio/Entertainment/Navigation - Service/Warranty Info.
- Audio/Navigation/RES - Warr. Exchange/Non-Warr Repair
- Audio/Entertainment/Navigation - Service/Exchange
- Antitheft System - Immobilizer System (Type 2)
- Antitheft System - Type 2 System Operation/Programming
- Immobilizer System - Type 2: Operation/Part Replacement
- Antitheft System - Key Code Duplicator
- Antitheft - Immobilizer System Information
- Trunk - Won't Open With The Remote Transmitter
- Keyless Remote Transmitter - Information
- Trunk - Will Not Open with Remote Transmitter
- Keyless Entry - Transmitter
- Keyless Entry - Transmitter ID/Programming
- Keyless Entry - Remote Transmitter Information
- Audio/Navigation/RES/iMID(R) - Warr Exchange/Non Warr Repair
- Restraints - Occupant Detection Initialization
- Restraint System - Occupant Detection Initialization
- 07-030 - 06/15/07
- Suspension - Rear Stabilizer Link is Broken
- Suspension - Rear Stabilizer Link(s) Broken
- Recall - Lower Ball Joints, Front
- Audio System - Remote Controls Malfunction
- Audio System - Remote Audio Controls Operate Improperly
- Electrical - GR8 Battery Diagnostic Station Update Info.
- Electrical - GR8 Battery Diagnostic Station Update
- Electrical - Battery Testing And Replacement
- Electrical - GR8(R) Battery Diagnostic Station Update
- Electrical - ED-18 Battery Analyzer Update Information
- Electrical - Battery Testing and Replacement
- Electrical - Battery Test Procedure/Equipment
- Battery - Testing Procedures
- Battery - Testing Procedure
- Disc Brake System - Brake Disc Refinishing Guidelines
- Brakes - Brake Disc Refinishing Guideline
- Brakes - Brake Disc Refinishing Guidelines
- Brake Discs - Refinishing Guidelines
- Brake Rotor - Refinishing Guidelines
- Brakes - ABS Wheel Sensor Harness Rubs Against Wheel
- CV Joint Boot - Band Tool
- M/T - Clutch Pedal Squeaking/Groaning Noise
- Clutch Pedal - Squeaking or Groaning noise
- Clutch Pedal - Noise
- A/T - In Warranty Exchange Program
- Recall - A/T Non Compliance Defect
- Recall - Ignition Switch Key Interlock
- Fuel Gauge - Inaccurate Readings
- Computers/Controls - Updating Control Units/Modules
- Computers/Controls - Module/Control Unit Updating
- Engine Controls - Updating ECM/PCM Software
- Computers/Controls - HIM Module Updating
- Engine Controls - Control Module Programming Procedure
- Engine Controls/Emissions - OBD II DTC's and Monitors
- Aftermarket OBD II Tester and Software Availability
- ECM/PCM - Replacement and Substitution
- MIL ON - DTC P0133 Primary Oxygen Sensor Falsely Set
- Vehicle - Recommended Materials
- Transmission/Engine - Hydraulic Lift Truck Usage
- Recall - DTC P0401 EGR Flow/EGR Port Clogging
- Engine - V6 Engine Oil Leaks
- Engine - Cylinder Block Oil Leaks
- Engine - Oil Leaks
- Vehicle - Recommended Service Materials
- Steering - Vehicle Pulls/Drifts to the Left/Right
- Engine Controls - Inspection of Idle Speed
- Engine Controls - Idle Speed Inspection
- All Technical Service Bulletins
- A/T - New ATF DW-1 Available
- Restraints - OPDS Unit Initialization Procedure
- Vehicle - Recommended Service Materials/Sealers/Lubricants
- Keyless Entry - Keyless Remote Transmitter Information
- Electrical - ED-18 Battery Analyzer Update Info.
- BULLETIN CANCELLATION NOTIFICATION
- Tools - Required Special Tools And Equipment
- Special Tool Loan Program
- Service Publications - Availability and Ordering
- ABS/TCS DTC's Caused By Poor Ground Connection
- ABS DTC 51 Or 53 - Diagnostic Tip
- ABS - Grunts When Doing A Self-Check
- Fuel Gauge and Low Fuel Indicator Accuracy Check
- Tools - Denso HLD-100 Halogen Leak Detector
- A/C - System Performance Testing
- A/C - Poor Cooling During Hard Acceleration
- A/C - Heater Blows Cold Air, A/C Blows Warm Air
- Engine/Transmission - Hydraulic Lift Truck usage
- Engine Oil Recommendations
- Blower (Heater) Motor Gets Hot and Blows A Fuse
- Wheel Bearings, Rear - Noise
- Wheel Bearings - Humming Or Growling
- Muffler Paint Peeling
- Engine Controls - MIL ON/DTC P0107or P0108 Set
- Ball Joint Removal and Installation Tools
- Recall 99V069000: Lower Ball Joint Replacement
- Accessory Trunk Spoiler - Damages Trunk Paint
- Rear Doors - Water Leaks To The interior
- Doors - Stick While Being Opened
- Moonroof Visor Seal - Splits
- Headliner/Windshield/Moonroof - Creaking/Popping
- Ceiling Light Area - Rattle
- Drivetrain - Clicking Noise On Low Speed Turns
- A/T - Leak From Cooler Line Banjo Bolt
- A/T - Avoiding Fluid Contamination
- A/T - Fixing Banjo Bolt Leaks
- A/T - Do Not Remove Torque Converter From Mainshaft
- M/T - Clutch Pedal Noise
- Clutch Master Cylinders Are Now Aluminum
- Emissions/Engine Controls - MIL ON/DTC P1457 (EVAP)
- Drivetrain - Revised CV Joint Boot Band/Installation
- Brakes - ABS Wheel Sensor Harness Rubs on Wheel
- Brake System - Indicator Lamp Stays ON
- Brakes - Brake Indicator Comes ON/Goes OFF
- Brake System - Don't Skip Diagnosis Steps in 03-078
- Alternator - Broken Bracket Or Mounting Bolt
- Recall 02V120000: Ignition Switch Defect
- Recall - Ignition Switch Replacement
- DTC P1456 and P1457 - Troubleshooting Update
- Recall - Throttle Body Air Screw Adjustment
- Emissions - MIL ON/DTC P0420 (Catalytic Converter) Set
- Emissions - MIL ON/DTC P0420 (Catalyst Efficiency)
- Catalytic Converter - Rotten Egg Smell
- Exhaust System - Catalytic Converter Noise
- Security System - Activates When Not Armed
- Interior - Seat Belts Slow to Retract
- Brakes - Disc Refinishing Procedure
- Fuel Gauge - Readings Are Inaccurate
- Suspension - Rattle From Rear Stabilizer Bar
- Recall - Ignition Switch Key Interlock Defect
- Rear Shelf Area - Creaking Noise
- Special Tool - Chassis EAR(TM), Diagnostic Tool
- Water Leak From Door. Check Rain Protector
- Wind Noise - Simple Way To Replicate
- Accessory Security System - Troubleshooting
- Alarm/Security System - Troubleshooting
- Keyless Remote Unlocks Gut Doesn't Lock Doors
- Security System Doesn't Arm
- HomeLink (R) - Skimpy Range
- Supplemental Restraint System - Inspection
- Antitheft - Security System Will Not Function
- Immobilizer Key - Key Code Duplicator
- MIL ON - P0304 and/or P0306 Codes
- Aftermarket On Board Diagnostic (OBD) II Tester
- MIL ON - DTC P0401 EGR Flow Insufficient
- Engine Controls - DTC Capture and Downloading
- Clearing DTCs and Setting ECM/PCM With The HDS
- Engine Controls - Clearing DTC's
- Instruments - Clock Light Inoperative
- Recall 97V220000: Seat Belt Retractor Defect
- Recall 97V220000: Seat Belt Anchor Defect
- Body - Wind Noise From the Top of the WIndshield
- Windshield Wipers - Blade Care and Replacement
- Glove Box Door - Rattle
- Engine - Oil Recommendation GF-4 Standard
- A/T - In-Warranty Exchange Program
- A/T Whine - Test Drive Tip
- A/T - Don't Test Drive With The MIL Or D Indicator On
- M/T - Bangs in Reverse Gear
- Audio Unit with CD Player/Changer - Error Codes
- Trunk - Will Not Open With Remote Transmitter
- Recall - DTC P0401 EGR Flow/EGR Port Clogging
- Troubleshooting DTCs - P1456 and P1457
- SRS - Indicator ON with No SRS DTC Set
- Wiring Terminal - Repair Instructions
- Updated Troubleshooting - DTCs P1456 and P1457
- M/T - Hard To Shift Into 1st Gear, Grinds Into Reverse
- Audio - Remote Audio Controls Don't Work Properly
- Audio System - Never Play CD's With Adhesive Labels
- Body - Minor Paint Finish Repair
- Paint - Codes/Cross References
- Power Windows/Door Locks - Do Not Work
- Ceiling Light - Flickers
- Ceiling Light Doesn't Work
- Audio System - Remote Controls Don't Work Properly
- Recall 98V018000: A/T Park Pawl Modification
- Recall 98V018000: Parking Pawl Modification
- Recall 03V423000: Ignition Cylinder Inspection/Repair
- Interior - Side-to-Side Looseness in Driver's Power Seat
- Antitheft System - Panic Alarm Sounds By Itself
- M/T - 5th Gear Grinds On Upshift
- Body - Moonroof Seal Squeaks
- Tools - New Fuel Pressure Gauge and Replacement Parts
- Interior - Seat Back Panel Loose/Detached
- Body - Plastic Body Clip Removal Tips
- Torque Converter Oil Seal - Installation Tool
- Suspension - Replaceable Ball Joint Assemblies
- Tires - Tubless Tire Repair Information
- Suspension - Rear Stabilizer Link Broken
- Emissions - EVAP Testing Using The PGM Tester
- Engine Controls - Idle Speed Inspection With PGM Tester
- Engine - Idle Vibration/Harsh Shifting
- Paint - Industrial Fallout Paint Damage
- Body - Unibody Repair Guidelines
- A/C - Refrigerant Leak Detection
- Engine - Oil Leaks From Front/Middle/Rear of Engine
- CAMPAIGN CANCELLATION NOTIFICATION
- Body - Windshield Moulding Warped/Deformed
- Steering/Suspension - Vehicle Pulls Left/Right
- Electrical - Battery Testing and Replacement Information
- Engine - Connecting Rod Damage Information
- A/C - Heater Blows Cold Air/A/C Blows Hot Air
- A/T - ATF Cooler Cleaner Information
- Emissions - OBD II DTC's And Associated Monitors
- A/T - Vehicle Speed Sensor Installation Precautions
- Electrical - Battery Replacement Precautions
- Starting System - Unable To Key In Ignition Switch
- Accessories - HomeLink(R0 Troubleshooting Considerations
- Computers/Controls - Initialization Procedure Info.
- Engine Controls - Test Drive Precautions
- Audio System - CD/DVD Precautions
- Interior - Fabric Upholstery Wrinkle Information
- Body - Chrome/Stainless Trim Staining Information
- Brakes - Brake Disc Refinishing Information
- A/T - Cooler Flushing Equipment Information
- Electrical - GR8 Battery Diagnostic Station Update Information
- Antitheft - Immobilizer System (Type 2) Information
- Audio,Navigation, RES - Warr. Exchange/Non-Warr. Repair