Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Hybrid System - IMA Indicator ON/DTC's P1447/P1449
- Body - Driver Window Auto-Down Function Inoperable
- Emissions/Engine Controls - MIL ON/DTC P1457 (EVAP)
- Rear Window Wiper Motor - Radio Static
- Interior - Seat Belts Slow to Retract
- Campaign - Park Brake Lever Update
- Engine/Motor Controls - IMA Indicator ON/DTC's Set
- Steering/Suspension - Vehicle Pulls Left/Right
- Recommended Repairs
- Superceded Bulletins
- 12-048 - 09/25/12
- 90-011 - 05/02/09
- 89-022 - 06/18/04
- 99-018 - 04/20/06
- 02-025 - 11/12/2002
- 98-019 - 05/13/05
- 06-001 - 01/16/06
- 00-070 - 09/23/03
- 98-011 - 02/05/02
- 86-020 - 06/08/99
- 02-035 - 06/25/02
- 01-029 - 03/20/01
- 01-023 - 09/01/02
- 01-013 - 02/06/01
- 00-093 - 11/21/00
- 00-088 - 04/03/01
- 00-088 - 08/14/02
- Body - Driver Window Auto-Down Function Inoperative
- Body - Recommended Repair Materials
- Body - Recommended Sealers And Adhesives
- Body - Recommended Sealers/Repair materials
- Audio/Navigation/RES - Warr. Exchange/Non-Warr. Repair
- Audio/Navigation/RES Unit - Warranty Exchange/Repair
- Audio/Entertainment/Navigation - Service/Warranty Info.
- Audio/Navigation/RES - Warr. Exchange/Non-Warr Repair
- Audio/Entertainment/Navigation - Service/Exchange
- Antitheft System - Immobilizer System (Type 2)
- Antitheft System - Type 2 System Operation/Programming
- Immobilizer System - Type 2: Operation/Part Replacement
- Keyless Entry - Transmitter
- Keyless Entry - Transmitter ID/Programming
- Keyless Entry - Remote Transmitter Information
- Audio/Navigation/RES/iMID(R) - Warr Exchange/Non Warr Repair
- Restraints - Occupant Detection Initialization
- Restraint System - Occupant Detection Initialization
- 07-030 - 06/15/07
- Electrical - GR8 Battery Diagnostic Station Update Info.
- Electrical - GR8 Battery Diagnostic Station Update
- Electrical - Battery Testing And Replacement
- Electrical - GR8(R) Battery Diagnostic Station Update
- Electrical - ED-18 Battery Analyzer Update Information
- Electrical - Battery Testing and Replacement
- Electrical - Battery Test Procedure/Equipment
- Battery - Testing Procedures
- Battery - Testing Procedure
- Disc Brake System - Brake Disc Refinishing Guidelines
- Brakes - Brake Disc Refinishing Guideline
- Brakes - Brake Disc Refinishing Guidelines
- Brake Discs - Refinishing Guidelines
- Brake Rotor - Refinishing Guidelines
- Computers/Controls - Updating Control Units/Modules
- Computers/Controls - Module/Control Unit Updating
- Engine Controls - Updating ECM/PCM Software
- Computers/Controls - HIM Module Updating
- Engine Controls - Control Module Programming Procedure
- Engine Controls/Emissions - OBD II DTC's and Monitors
- Engine Controls - MIL ON/DTC P0420
- IMA Battery Module - Warranty Exchange Program
- Campaign - Premature IMA Battery Module Failure
- Campaign - Warranty Extension for IMA Battery Module
- IMA System - Indicator ON/DTC P1447 or P1449 Set
- 12-048 - 10/05/12
- 12-048 - 09/21/12
- 12-048 - 09/05/12
- Hybrid System, IMA Battery Exchange Program Information
- Hybrid System - IMA Battery Exchange Program Information
- Hybrid System - IMA Battery Module Warranty Extension
- Hybrid System - IMA Battery Warranty Extension
- Hybrid Systems - IMA Battery Exchange Program
- Hybrid System - IMA Battery Warranty Exchange Program
- Hybrid System - IMA Indicator ON/DTCs P1447/P1449
- Hybrid Systems - IMA Battery Warranty Exchange Program
- Campaign - Warranty Extension for IMA Battery
- 06-027 - 02/05/08
- Campaign - Extended IMA Battery Warranty
- Campaign - IMA Battery, Warranty Extension
- Campaign - IMA Battery Warranty Extension
- Hybrid Systems - IMA Battery Module Exchange Program
- IMA Battery Module - Warranty Exchange program
- Campaign - IMA Battery Module Warranty Extension
- Vehicle - Recommended Materials
- Vehicle - Recommended Service Materials
- Steering/Suspension - Vehicle Pulls Right/Left
- Steering/Suspension - Vehicle Pulls/Drifts To One Side
- Steering/Suspension - Vehicle Pull/Drift To One Side
- Steering - Vehicle Pulls/Drifts to the Left/Right
- All Technical Service Bulletins
- A/T - New ATF DW-1 Available
- Hybrid Systems - IMA Battery Module/Junction Board Transfer
- Recall - Combination Light Switch/Headlamp Wiring Repair
- Restraints - OPDS Unit Initialization Procedure
- Vehicle - Recommended Service Materials/Sealers/Lubricants
- Hybrid System - IMA Battery Exchange Program Info.
- Keyless Entry - Keyless Remote Transmitter Information
- Hybrid System - IMA Indicator ON/DTC's P1447/P1449
- Electrical - ED-18 Battery Analyzer Update Info.
- BULLETIN CANCELLATION NOTIFICATION
- Tools - Required Special Tools And Equipment
- ABS - Grunts When Doing A Self-Check
- Fuel Gauge Sending Unit - Service Manual Revision
- A/C - System Performance Testing
- A/C - Heater Blows Cold Air, A/C Blows Warm Air
- Engine Oil Recommendations
- Gas Tank - Fuel Pump/Sending Unit Installation Tip
- Blower (Heater) Motor Gets Hot and Blows A Fuse
- Body - Driver Window Auto-Down Function Inoperable
- A/T - Avoiding Fluid Contamination
- A/T - Fixing Banjo Bolt Leaks
- A/T - Do Not Remove Torque Converter From Mainshaft
- Campaign - ECM Update
- Campaign - Integrated Motor Assist Controller Update
- Recall - Emissions/ECM Replacement
- Emissions/Engine Controls - MIL ON/DTC P1457 (EVAP)
- Drivetrain - Revised CV Joint Boot Band/Installation
- Catalytic Converter - Rotten Egg Smell
- Exhaust System - Catalytic Converter Noise
- Rear Window Wiper Motor - Radio Static
- Interior - Seat Belts Slow to Retract
- Driver's Air Bag - Replace Torx Bolts Properly
- Speedo/Odometer Read Excessive Speed and Distance
- Recall 04V086000: Headlamp Switch/Connector Defect
- Suspension - Drifting and Pulling At Highway Speeds
- Special Tool - Chassis EAR(TM), Diagnostic Tool
- Interior and Exterior Trim - Tool To Make Removal A Snap
- Air Fresheners - Bad News For Paint Or Plastic
- Wind Noise - Simple Way To Replicate
- Supplemental Restraint System - Inspection
- Immobilizer Key - Key Code Duplicator
- Engine Controls - DTC Capture and Downloading
- Clearing DTCs and Setting ECM/PCM With The HDS
- DTC 1600 and 1601 Code Description
- Engine Controls - Clearing DTC's
- Windshield Wipers - Blade Care and Replacement
- Engine - Oil Recommendation GF-4 Standard
- A/T - In-Warranty Exchange Program
- SRS - Indicator ON with No SRS DTC Set
- Wiring Terminal - Repair Instructions
- M/T - Hard To Shift Into 1st Gear, Grinds Into Reverse
- Audio System - Never Play CD's With Adhesive Labels
- Campaign - Park Brake Lever Update
- Engine/Motor Controls - IMA Indicator ON/DTC's Set
- Body - Plastic Body Clip Removal Tips
- Tires - Tubless Tire Repair Information
- Paint - Industrial Fallout Paint Damage
- Body - Unibody Repair Guidelines
- Music Link(R) - System Information/Diagnostics
- A/C - Refrigerant Leak Detection
- Campaign - ECM Update for MIL ON/DTC P0420
- Campaign - Premature IMA Battery Module Failures
- Hybrid Systems - High Temp. Effect ON Hybrid Batteries
- Steering/Suspension - Vehicle Pulls Left/Right
- Electrical - Battery Testing and Replacement Information
- Engine - Connecting Rod Damage Information
- A/C - Heater Blows Cold Air/A/C Blows Hot Air
- A/T - ATF Cooler Cleaner Information
- Emissions - OBD II DTC's And Associated Monitors
- A/T - Vehicle Speed Sensor Installation Precautions
- Electrical - Battery Replacement Precautions
- Starting System - Unable To Key In Ignition Switch
- Computers/Controls - Initialization Procedure Info.
- Audio System - CD/DVD Precautions
- Interior - Fabric Upholstery Wrinkle Information
- Body - Chrome/Stainless Trim Staining Information
- Brakes - Brake Disc Refinishing Information
- A/T - Cooler Flushing Equipment Information
- Campaign - IMA Battery Module Warranty Extension
- Electrical - GR8 Battery Diagnostic Station Update Information
- Antitheft - Immobilizer System (Type 2) Information
- Audio,Navigation, RES - Warr. Exchange/Non-Warr. Repair
- Campaign - IMA Battery Warranty Extension