Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Steering - Steering Rack High Pitched Noise
- Cooling System - Engine Overheating Condition
- Engine - Rattle Noise on Start Up
- Engine - Start-Up and Idle Rattle
- Brakes - Judder/Shudder/Pulsation
- Battery - Discharges
- Engine - No Start/Idle/Driveability Concerns
- Engine - Poor Performance/Low Power
- Throttle Cable - Limp Home Mode/DTC P1121/P1632
- Telephone - Interference Noise During Call
- Engine - Oil Leaks from Oil Filter
- A/T Selector Lever - Difficult to Shift From PARK
- Heater Hoses - Coolant Leaks
- Door Mirrors - Wind Noise
- A/T - Default to Limp Home Mode
- Engine - No Start/Unsatisfactory Idle/Poor Driveability
- A/T - Oil Seepage from Electrical Connector
- Wheels/Tires - Steering Wheel/Seats Vibration
- Wheels/Tires - Vibration/Shimmy
- Radio Station - Breaks in Reception
- Front Undertray - Detached Mountings
- Center High Mounted Stop Light - Rattle/Vibration
- Front Passenger Seat - Rattles When Unoccupied
- Keyless Entry - Can't Lock Vehicle Using Remote Fob
- Recommended Repairs
- Superceded Bulletins
- 418-08 - 10/01/98
- 418-08 - 02/01/02
- 310-06 - 06/01/00
- 310-05 - 08/01/00
- 3-152 - 12/01/96
- 206-07- 07/01/98
- 206-07 - 04/01/00
- 204-S499 - 04/01/03
- 204-11 - 02/01/00
- 1-104 - 05/01/99
- Windshield Wiper - Streaking or Juddering
- Heated Windshield Harness Connectors - Water Ingress
- Radio - Frequency, Cut Out Problems
- Recall - Engine Stalls/Cuts Out
- Campaign - S701 MIL ON, Excess Engine Noise
- Engine Controls - Removing Seized O2 Sensors
- Tires/Wheels - Vibration/Shimmy
- Heater Hoses - Coolant Leakage
- Recall - PROM Update for Engine Stalling
- Engine - Loss of Performance/Revised Intake Duct Parts
- Engine Performance - Difficult Cold Start
- Engine - Difficult Cold Start
- All Technical Service Bulletins
- Warranty - Re-acquired Coverage
- Engine - Setup Using PDU
- JTIS - Shop Manual Issue 8
- JTIS - CD ROM Shop Manual Issue 7
- Battery - Disconnect Prior to Control Module Service
- Trip Computer - Operation
- Instrument Panel Harness - Incorrectly Routed
- Power Steering - Diagnosis/Pressure Testing
- Engine Controls - Hard/No Start Diagnostic Flowcharts
- A/C System - Flush After Compressor Failure
- Tools - Wheel Bearing Installer/Remover
- Steering - Steering Rack High Pitched Noise
- Engine - Coolant Pump Replacement Guideline
- Cooling System - Engine Overheating Condition
- Engine - Rattle Noise on Start Up
- Engine - Start-Up and Idle Rattle
- Wheels and Hubs - Corrosion Prevention
- Engine/Wheels - Revised Dipstick/Inflation Adapters
- Child Seat Mounting Eyes - Installation
- Interior - Leather Upholstrey - Care and Maintenance
- Sliding Roof - Diagnosis and Repair
- Front Wheel Hub - Accumulation of Excess Grease
- Brakes - Judder/Shudder/Pulsation
- Battery - Discharges
- Engine - No Start/Idle/Driveability Concerns
- Engine - Poor Performance/Low Power
- Throttle Cable - Limp Home Mode/DTC P1121/P1632
- Telephone - Interference Noise During Call
- Cellular Phone - Warranty Policies/Procedures
- Engine - Oil Leaks from Oil Filter
- Tool - ABS Rotor Nut Socket Tool
- Lighting - Headlamp Condensation Guidelines/Repair
- Brake Switch - Simplified Inventory
- A/T Selector Lever - Difficult to Shift From PARK
- Heater Hoses - Coolant Leaks
- Tool - Subframe Bushing
- Tools - Front Wishbone Bushing Installers
- Suspension - Revised Front Bushings/Replacement
- Campaign - Control Arm Bushing Inspection/Replacement
- Suspension - Stabilzer Bar Bushings Lubrication
- Rear Suspension Hub Carrier Bolts - Torque Revised
- Tools - Monostrut Bushing Replacement Tool
- Door Mirrors - Wind Noise
- Vehicle - Pressure Wash, Cleaning, Detailing Chemicals
- Body - Draft Welt Loose - Front Door Opening
- Front Bumper Harness - Revised, Shorter
- Airbags - Deactivation Service Kits
- Airbag - Specification Changes
- PDU Software - New
- ECM - Replacement Questionaire
- A/T - Default to Limp Home Mode
- Engine - No Start/Unsatisfactory Idle/Poor Driveability
- PDU Software - JTP 627/5 Update
- PDU Software - MPA Lock Up/Recovery Procedure
- PDU - Software Update
- PDU - Software Updates
- PDU - New Software
- JTIS 8 - Electrical Guides, DTC Summaries Added
- Engine Control - Driveability Diagnosis Information
- Engine - Diagnosis of AJ6 Driveability Symptoms
- Recall - EGR Pipe Replacement
- Coolant - Extended Life
- A/T - Defective, Requires Replacement
- A/T - Oil Seepage from Electrical Connector
- Campaign - Engine Breather Scheduled Cleanings
- Steering Column Cassette - Replacement Procedure
- Tool - Camshaft Drive Revised Procedure
- PDU Software - New Available
- Engine Oil - Revised Viscosity Ratings
- Engine Oil Viscosity - Revised Ratings
- Wheels/Tires - Steering Wheel/Seats Vibration
- Wheels/Tires - Vibration/Shimmy
- Seat Belt Pretensioners - Handling Precautions
- A/T - Pressure Regulators Incorrectly Identified
- Radio Station - Breaks in Reception
- Front Undertray - Detached Mountings
- Center High Mounted Stop Light - Rattle/Vibration
- Campaign - License PLate Light Bulb Flickering
- CVVT Retaining Bolt - Revised Torque
- Front Passenger Seat - Rattles When Unoccupied
- Seat/Steering/Mirror Memory System - Diagnostics
- Tools - Differential Pinion Seal
- Pinion Seal - Oil Leak
- Interior - Approved Cleaning Products
- Body - Windshield Damage Diagnostic Guide
- Engine Controls - Removal of Seized Oxygen (O2) Sensors
- Keyless Entry - Can't Lock Vehicle Using Remote Fob
- Engine - Aluminum Thread Repair Information
- Recall - Engine Stalling Issues