Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Drivetrain - Driveline Noise
- Engine/A/T - Oil Leak Misdiagnosis
- Driveline - Vibration While Driving
- M/T - Difficulty Engaging 1st or Reverse Gear
- Fuel System - Rough Idle/Hesitation
- Body - Rattle/Squeak From Brake/Clutch Pedal Area
- Interior - Power Seats Inoperative
- Interior - Front Seat Motor Noisy
- Instruments - Intermittent/Inoperative Fuel Gauge
- Brakes - Chirp/Creak Noise From Rear of Vehicle
- Wipers - Squeaking/Streaking/Smearing/Juddering
- Instruments - Interior Rearview Mirror Loose
- A/T - Whining Noise From Shift Cables
- Body - Exterior Door Handles When Released
- Body - Exterior Door Handle Stiff or Inoperative
- Interior - Sun Visor Mirror Cover Loose
- Body - Luggage Compartment Lid Doesn't Open Properly
- A/C, Interior - Passenger Seat Heater Int. Inoperative
- Interior - Premature Front Seat Backrest Wear
- Ignition System - MIL ON/DTC's P0341/P1341
- Body - Front/Rear Door Glass Won't Close All The Way
- M/T - Rattle From The Clutch Area at Idle
- Drivetrain - Transfer Case Oil Leak
- A/C - Windshield Heater is Inoperative
- Suspension - Front End Creak When Braking On Bumps
- Body - Interior/Exterior Door Handle Binds/Stiff/Squeaks
- Electrical - MIL ON/Misfire DTC's Set
- Body - Rust Beneath Trunk Lid Trim Panel
- Engine - Knocking at 1,000-2,300 RPM Under a Light Load
- Interior - Tonneau Cover Bar Locating Pegs Loose/Sheared
- Suspension - Rear Brake Moan At Slow Speed/Reverse
- Cooling System - Leaks From Coolant Expansion Tank
- Body - Quarter Glass Trim Is Loose
- Power Steering System - Squeaking Noises
- Brakes - Rear Brakes Moan at Slow Speeds or in Reverse
- Steering - Power Steering Leak/Heavy/Noisy Diagnostics
- Suspension - Front End Knocking Noises
- Keyless Entry - Can't Lock Vehicle Using Remote Fob
- ABS/TCS - DSC Lamp ON/DTC U1900 After Start Up
- A/C - Does Not Cool Sufficiently
- Body - Front Door Window Complaints
- Brakes - Rear Brake Moan in Reverse
- Superceded Bulletins
- S5274 - 01/01/08
- XT204-04 - 12/01/04
- S204-10 - 12/01/04
- XT501-026 - 11/01/06
- XT204-08 - 04/01/05
- XT501-21 - 10/01/04
- XT310-05 - 02/01/05
- XT211-01 - 02/01/04
- Body - Rear Quarter Window Trim loose
- Body - Wind Noise From Top of Door Window
- Body - Front Door Glass Won't Fully Close/Rattles
- Body - Exterior Door Handle Stiff/Inoperative
- Campaign - Navigation Module Reprogramming
- Campaign - Keyless Remote Modification
- Brakes Rear Brake Moan in Reverse
- Brakes - DSC Lamp ON/DTC U1900 Stored in Memory
- Brakes - Rear Brake Moan When Backing
- ABS/TCS - DSC Lamp ON After Engine Start Up
- ABS/TCS - DSC Lamp ON After Cranking
- Instruments - Intermittent Fuel Gauge Operation
- Recall - ECM/TCM Software Updates For OBD Improvements
- Recall - ECM/TCM Update For OBD Enhancements
- Dynamic Stability Control - Lamp ON/DTC U1900 Set
- Engine Controls - Removing Seized O2 Sensors
- Power Steering - Squeaking Noise
- Wheels/Tires - Permanent Tire High Spot Marking
- All Technical Service Bulletins
- Body/Frame - Squeaks and Rattle Kit Availability
- Interior - Overhead Console Switch Availability
- Drivetrain - Driveline Noise
- Engine/A/T - Oil Leak Misdiagnosis
- Steering - Fluid Reservoir Replacement Criteria Update
- Driveline - Vibration While Driving
- M/T - Difficulty Engaging 1st or Reverse Gear
- Drivetrain - Transfer Case Removal Procedure Update
- Fuel System - Rough Idle/Hesitation
- Body - Rattle/Squeak From Brake/Clutch Pedal Area
- Fuel System - DO NOT CLEAN Electronic Throttle Body
- Interior - Power Seats Inoperative
- Interior - Front Seat Motor Noisy
- Campaign - Navigation Control Module Reprogramming
- Instruments - Intermittent/Inoperative Fuel Gauge
- Brakes - Chirp/Creak Noise From Rear of Vehicle
- Brakes - Revised Parking Brake Cable Adjustment Spec.
- Recall - Fuel Tank Filler Cap Seal Replacement
- Wipers - Squeaking/Streaking/Smearing/Juddering
- Instruments - Interior Rearview Mirror Loose
- Suspension - Front Control Arm R and I Time Revision
- A/T - Whining Noise From Shift Cables
- Restraint System - Flash Codes and PID Code Definitions
- Navigation System - Diagnostic Procedures
- Body - Exterior Door Handles When Released
- Body - Exterior Door Handle Stiff or Inoperative
- Interior - Sun Visor Mirror Cover Loose
- Keyless Entry - Remote Transmitter Programming
- Body - Luggage Compartment Lid Doesn't Open Properly
- A/C, Interior - Passenger Seat Heater Int. Inoperative
- Interior - Premature Front Seat Backrest Wear
- ABS/TCS - Sensor Cluster Diagnostics
- Ignition System - MIL ON/DTC's P0341/P1341
- Body - Front/Rear Door Glass Won't Close All The Way
- Interior - Approved Cleaning Products
- M/T - Rattle From The Clutch Area at Idle
- Drivetrain - Transfer Case Oil Leak
- ABS/TCS - Wheel Speed Sensor Diagnostics
- Brakes - ABS Module CAN Fault Diagnosis
- Brakes - ABS Module Fault Diagnostics
- A/C - Windshield Heater is Inoperative
- Suspension - Front End Creak When Braking On Bumps
- Body - Interior/Exterior Door Handle Binds/Stiff/Squeaks
- Electrical - MIL ON/Misfire DTC's Set
- Body - Rust Beneath Trunk Lid Trim Panel
- Body - Windshield Damage Diagnostic Guide
- Engine - Knocking at 1,000-2,300 RPM Under a Light Load
- Instruments - Instrument Cluster Diagnostics
- Interior - Tonneau Cover Bar Locating Pegs Loose/Sheared
- A/T - Selector Lever Part Change
- Suspension - Rear Brake Moan At Slow Speed/Reverse
- Cooling System - Leaks From Coolant Expansion Tank
- Body - Quarter Glass Trim Is Loose
- Power Steering System - Squeaking Noises
- Brakes - Rear Brakes Moan at Slow Speeds or in Reverse
- Steering - Power Steering Leak/Heavy/Noisy Diagnostics
- A/C - Revised A/C Compressor R and I Labor Time
- Steering - Revised Steering Gear Removal/Installation
- Tires - Permanent High Spot Marking on Sidewalls
- Engine Controls - Removal of Seized Oxygen (O2) Sensors
- Suspension - Front End Knocking Noises
- A/T - Revised Removal/Installation Procedure
- M/T - Revised Removal/Installation Procedure
- Suspension - Rear Underbody Noise
- Campaign - Keyless Entry Remote Fob Modification
- Keyless Entry - Can't Lock Vehicle Using Remote Fob
- Engine - Aluminum Thread Repair Information
- Body - Revised Front Door Lock Actuator/Cable Service
- ABS/TCS - DSC Lamp ON/DTC U1900 After Start Up
- Recall - ECM/TCM Update For OBD Compliance
- A/C - Does Not Cool Sufficiently
- Body - Front Door Window Complaints
- Brakes - Rear Brake Moan in Reverse