Powertrain Management: Technical Service Bulletins

• Recalls
  • Emissions
    • Recall - Trap Oxidizer Replacement
      • Overview
      • Work Instructions
      • Owner Letter
  • Generals
    • Campaign - Oxidation Catalyst Replaces Trap Oxidizer
      • Overview
      • Owner Letter
      • Work Instructions
        • Overview
        • Procedure
• Customer Interest
  • Fuel Rack Position Sensor - Testing
  • Fuel Hose - Updated Part
  • Turbocharger - Noisy Air Recirculating Valve
  • Turbocharger - Updated Compressor Housing
  • Fuel - Injection Pump, Modified Vibration Damper
  • Fuel - Aneroid Compensator (ALDA), Modified
  • Diesel Engine - MIL ON/Hard Start/Stall In Cold Temps.
• By Symptom
  • Abnormal wear/deterioration
    • Fuel Rack Position Sensor - Testing
    • Rubber Bumpers for Air Filter Housing are Cracked
  • Customer Interest
    • Fuel Rack Position Sensor - Testing
    • Fuel Hose - Updated Part
    • Turbocharger - Noisy Air Recirculating Valve
    • Turbocharger - Updated Compressor Housing
    • Fuel - Injection Pump, Modified Vibration Damper
    • Fuel - Aneroid Compensator (ALDA), Modified
    • Diesel Engine - MIL ON/Hard Start/Stall In Cold Temps.
  • Driveability
    • Fuel - Additives for Turbodiesels (California)
    • Fuel Rack Position Sensor - Testing
  • Inoperative
    • Scan Tool (Impulse Counter ) - Failure, Improper Hook-Up
  • Leaks
    • EGR - Vacuum Transducer Leak Test
  • No shift/Incorrect gear engagement
    • A/T - No 2-3 Upshift at Full Throttle/At Engine Cutout
  • Noise
    • Fuel Hose - Updated Part
    • Turbocharger - Noisy Air Recirculating Valve
    • Turbocharger - Updated Compressor Housing
  • Recalls
    • Campaign - Oxidation Catalyst Replaces Trap Oxidizer
      • Overview
      • Owner Letter
      • Work Instructions
        • Overview
        • Procedure
    • Recall - Trap Oxidizer Replacement
      • Overview
      • Work Instructions
      • Owner Letter
  • Vibration
    • Fuel - Injection Pump, Modified Vibration Damper
  • Warping
    • A/T - No 2-3 Upshift at Full Throttle/At Engine Cutout
• All Technical Service Bulletins
  • Engine Control - Engine Control Module (N3/10) Flashing
  • Computers/Controls - Module Programming Precautions
  • Electrical - Electrostatic Discharge Damage Prevention
  • Vehicle - New Dealer Technical Bulletin
  • Tools - Hand-Held Tester, New Modules
  • Glow Plug Lamp Does Not Come ON, or Works Intermittently
  • Fuel - Additives for Turbodiesels (California)
  • Engine - Warning About Carbon Cleaning
  • A/T - No 2-3 Upshift at Full Throttle/At Engine Cutout
  • Fuel Rack Position Sensor - Testing
  • Fuel Rack Position Sensor - Extension Cable
  • Knocking Noise at Idle From Fuel Return Line
  • Injector Pump - Authorized Bosch Dealers
  • Engine is Difficult to Start at Operating Temperatures
  • Fuel Injector - Production Change
  • Fuel Hose - Updated Part
  • Turbocharger - Noisy Air Recirculating Valve
  • Turbocharger - Updated Compressor Housing
  • Emission Systems - Service Guidelines
  • Rubber Bumpers for Air Filter Housing are Cracked
  • Tubocharger - Waste Gate, Updated Repair Kit
  • EGR - Vacuum Transducer Leak Test
  • EGR - Vacuum Transducer, One Vent Line
  • Campaign - Oxidation Catalyst Replaces Trap Oxidizer
    • Overview
    • Owner Letter
    • Work Instructions
      • Overview
      • Procedure
  • Recall - Trap Oxidizer Replacement
    • Overview
    • Work Instructions
    • Owner Letter
  • Electronic Components - Warning Against Repair
  • Maintenance - Factory Approved Service Products
    • Overview
    • General Information
    • Engine Oil
    • Other Lubricants and Fluids
    • Fuel Requirements
      • 1. Gasoline Engines
      • 2. Diesel Engines
  • Policy - Vehicle Emission System Tampering
  • I/M Emission Testing on Dynamometer
  • Scan Tool (Impulse Counter ) - Failure, Improper Hook-Up
  • Policy - HHT Warranty & Precautions
  • Hand-Held Tester (HHT) - Updated Modules
  • Fluids - Approved Service Products Info.
    • Overview
    • Approved Engine Oils
    • Differential Transmission Steering
    • Multi-Purpose Greases
    • Fuel Requirements
  • Fuel - Injection Pump, Modified Vibration Damper
  • Injection Pump - High-Pressure Timing
  • Injection Pump - Updated Checking Procedure
    • Overview
    • Checking Start of Delivery W/ Engine Running - RIV Method
    • Checking Start of Delivery W/ Engine Not Running
    • Special Tool Information
  • Fuel - Low Sulfur Diesel
  • Warranty - Return of Fuel System Components
  • Fuel - Fuel Drain Hoses & Portable Fuel Tanker
  • Fuel - Aneroid Compensator (ALDA), Modified
  • Overvoltage Relay/Harness - Update
  • Engine - Special Tool, Compression Recorder
  • Engine - Compression Recorder Tool
  • Diesel Engine - MIL ON/Hard Start/Stall In Cold Temps.
  • Emissions - I/m Dynamometer Emissions Testing