Powertrain Management: Technical Service Bulletins

• Recalls
  • Campaign - EGR Valve Replacement
• Customer Interest
  • Computers - Inadvertent MIL ON Failure Explanation
  • Cruise Control Inoperative
• By Symptom
  • Customer Interest
    • Computers - Inadvertent MIL ON Failure Explanation
    • Cruise Control Inoperative
  • Erratic Operation
    • Engine - Cuts Out When Stopping/Intermittent Idle Surge
    • Engine - Total/Momentary Stall/Restarts After Short Wait
  • False instrument warning light/gauges
    • DTCs 57/60/63 Control Module Memory Malfunction
  • Inoperative
    • Scan Tool (Impulse Counter ) - Failure, Improper Hook-Up
    • Cruise Control Inoperative
  • Recalls
    • Campaign - EGR Valve Replacement
• All Technical Service Bulletins
  • Fuel System - Use Of E10 Fuel
  • Engine Control - Engine Control Module (N3/10) Flashing
  • Computers/Controls - Module Programming Precautions
  • Electrical - Electrostatic Discharge Damage Prevention
  • Vehicle - New Dealer Technical Bulletin
  • Tools - Hand-Held Tester, New Modules
  • Engine - Warning About Carbon Cleaning
  • Policy - Fluke Meter Approved
  • Fuel - High Idle After Cold Start/Future Recalls
  • Noisy Fuel Pump
  • Ignition - Caution about Spark Plug Wrenches
  • Control Module - ECM Tips and Application Guide
  • Control Module - (HFM-SFI) Modification
  • DTCs 57/60/63 Control Module Memory Malfunction
  • Engine Does Not Start or Surges at Idle
  • Engine - Cuts Out When Stopping/Intermittent Idle Surge
  • Engine, Shakes, Misses, and Dies at Idle
  • Protective Screen on Mass Air Flow Sensor Damaged
  • Battery Discharges After Extended Parking Time
  • Battery Discharged/Electronic Damage - After Jump Start
  • DLC - 9-Pole Diagnostic Connector - Deleted
    • General Information
    • Equipment Hookup
    • Oscilloscope Pattern #1
    • Oscilloscope Pattern #2
    • Oscilloscope Pattern #3
    • Oscilloscope Pattern #4
    • Checking Engine RPM Signal
  • Engine - Total/Momentary Stall/Restarts After Short Wait
  • Emissions - Catalytic Converter EPA Replacement Warning
  • Cruise/Idle Speed Control - Contact Box Modification
  • Radio Interference in AM range
  • Installing Interference Suppression Filters
  • Ignition - Checking with Engine Analyzers
    • Overview
    • A. Engine 104 / 111 Model Years 93/94 With HFM - SFI
    • B. Engine 119 / 120 Model Year 1996 With ME - SFI 1.0
  • Maintenance - Factory Approved Service Products
    • Overview
    • General Information
    • Engine Oil
    • Other Lubricants and Fluids
    • Fuel Requirements
      • 1. Gasoline Engines
      • 2. Diesel Engines
  • I/M Emission Testing on Dynamometer
  • Computers - Inadvertent MIL ON Failure Explanation
  • Impulse Readout of LH-SFI Control Module
  • Engine - Poor Power Output at Operating Temperature
  • Engine Does Not Start at Temperatures Below 5 Degrees C
  • Hand-Held Tester - Module Overview
  • Hand-Held Tester (HHT) - Updates
    • Overview
    • A. Ordering Information
    • B. HHT Printer Cable
    • C. HHT Module Program Update Service
    • D. Warranty/Repair Info for HHT Hardware (Tool Warranty)
    • E. General Information/Precautions
  • Tools - Hand-Held Tester, Module Updates
  • Tools - Hand-Held Tester (HHT), System Updates
  • Computer Control Systems - Diagnostic Analyzers
  • EGR Valve - Testing
  • Scan Tool (Impulse Counter ) - Failure, Improper Hook-Up
  • Policy - HHT Warranty & Precautions
  • Hand-Held Tester (HHT) - Updated Modules
  • Cruise Control Inoperative
  • Campaign - EGR Valve Replacement
  • Engine Dies When Transmission is Put Into Gear
  • Ignition System - Wires with Crimp-On terminals
  • Warranty - Return of Fuel System Components
  • Fuel - Fuel Drain Hoses & Portable Fuel Tanker
  • No Speed Signal Momentarily
  • Engine is Difficult to Start When Warm
  • After ASD Control Replacement, ASD MIL Flashes
  • Engine Surge Felt at Idle
  • Emissions - I/m Dynamometer Emissions Testing