Powertrain Management: Technical Service Bulletins

• Customer Interest
  • Fuel System - Hard Start After Fuel Filter Replacement
  • Computers - Inadvertent MIL ON Failure Explanation
  • Cruise Control Inoperative
• By Symptom
  • Customer Interest
    • Fuel System - Hard Start After Fuel Filter Replacement
    • Computers - Inadvertent MIL ON Failure Explanation
    • Cruise Control Inoperative
  • Erratic Operation
    • Engine - Cuts Out When Stopping/Intermittent Idle Surge
    • Engine - Total/Momentary Stall/Restarts After Short Wait
  • False instrument warning light/gauges
    • DTCs 57/60/63 Control Module Memory Malfunction
  • Inoperative
    • Cruise Control Inoperative
  • No shift/Incorrect gear engagement
    • A/T - No 2-3 Upshift at Full Throttle/Engine Cutout
  • Starting problems
    • Fuel System - Hard Start After Fuel Filter Replacement
    • Alarm - DAS/Non-DAS Vehicles Diagnosis
      • Overview
      • A. Vehicles Without Drive Authorization System (DAS)
      • B. Vehicles With DAS
• All Technical Service Bulletins
  • Fuel System - Use Of E10 Fuel
  • Transmission Controls - Control Module Flashing Info.
  • Engine Control - Engine Control Module (N3/10) Flashing
  • Computers/Controls - Module Programming Precautions
  • Emissions - State I/M OBD II Check Information
  • Electrical - Electrostatic Discharge Damage Prevention
  • Policy - Fluke Meter Approved
  • A/T - No 2-3 Upshift at Full Throttle/Engine Cutout
  • Fuel System - Hard Start After Fuel Filter Replacement
  • Noisy Fuel Pump
  • Fuel System - Replacement Fuel Pump Adapter Harness
  • Control Module - (HFM-SFI) Modification
  • DTCs 57/60/63 Control Module Memory Malfunction
  • ASR MIL ON on Starting Engine, DTC C1022 Set
  • ASR MIL Comes On After Engine Start, Code C1022
  • Repairs for Faults of Electronic Ignition Switch
  • Alarm - DAS/Non-DAS Vehicles Diagnosis
    • Overview
    • A. Vehicles Without Drive Authorization System (DAS)
    • B. Vehicles With DAS
  • Engine - Cuts Out When Stopping/Intermittent Idle Surge
  • Engine, Shakes, Misses, and Dies at Idle
  • Protective Screen on Mass Air Flow Sensor Damaged
  • ECT/VAF Sensor - Harness Repair
  • Battery Discharged/Electronic Damage - After Jump Start
  • Ignition Key Difficult to Remove from Ignition Switch
  • Test of Electronic Ignition Switch
  • DLC - 9-Pole Diagnostic Connector - Deleted
    • General Information
    • Equipment Hookup
    • Oscilloscope Pattern #1
    • Oscilloscope Pattern #2
    • Oscilloscope Pattern #3
    • Oscilloscope Pattern #4
    • Checking Engine RPM Signal
  • Engine - Total/Momentary Stall/Restarts After Short Wait
  • MIL ON Various DTC's Set
  • Radio Interference in AM range
  • Installing Interference Suppression Filters
  • Ignition - Checking with Engine Analyzers
    • Overview
    • A. Engine 104 / 111 Model Years 93/94 With HFM - SFI
    • B. Engine 119 / 120 Model Year 1996 With ME - SFI 1.0
  • Incorrect Fuel Indication
  • Maintenance - Factory Approved Service Products
    • Overview
    • General Information
    • Engine Oil
    • Other Lubricants and Fluids
    • Fuel Requirements
      • 1. Gasoline Engines
      • 2. Diesel Engines
  • I/M Emission Testing on Dynamometer
  • Computers - Inadvertent MIL ON Failure Explanation
  • Emission/VIN Label - Availability
  • Engine - Poor Power Output at Operating Temperature
  • MIL ON Briefly When Ignition Turned ON
  • Computer Control Systems - Diagnostic Analyzers
  • Cruise Control Inoperative
  • Engine Dies When Transmission is Put Into Gear
  • Fuel - Fuel Drain Hoses & Portable Fuel Tanker
  • Making and Installing Auxiliary Wiring Harness
  • Pump Nozzle Switches Off Prematurely When Fueling
  • Engine is Difficult to Start When Warm
  • After ASD Control Replacement, ASD MIL Flashes
  • Emissions - I/m Dynamometer Emissions Testing