Campaign - Trunk Lid handle Strip Replacement
Campaign No. 2006100005, October 2006FILE:
SERVICE: GROUP 00 OF SERVICE INFORMATION BINDER
PARTS: GROUP I OF INFORMATION _ PARTS & ACCESSORIES BINDER
TO: ALL MERCEDES-BENZ CENTERS
SUBJECT:
MODEL 219 IWC EDITION AMG, MODEL YEAR 2006
REPLACE TRUNK LID HANDLE STRIP
This Service Campaign has been initiated because DCAG has determined that on the affected vehicles (see VIN range below) with option code Y20 (IWC: International Watch Company) the trunk lid handle strip (strip crossing the trunk lid and trunk release handle) may not uniformly contact the trunk lid. Dealer will replace the trunk lid handle strip.
Please review the Effective Serial Number chart located below, and if necessary, repair the subject vehicles during the vehicle's next service.
Prior to performing this Service Campaign:
- Please check VMI to insure the vehicle is involved and to determine if the vehicle has been previously repaired.
- Please review the entire Service Campaign bulletin.
Effective Serial Number Range
Approximately 54 vehicles are affected.
NOTE:
Every vehicle in the VIN range may not be included in the campaign. VMI must always be checked before performing campaigns to verify that the campaign is required on a specific vehicle. VMI always overrides the bulletin in reference to a specific vehicle's inclusion in a particular campaign. Please also note that Recall and Service Campaigns do not expire and may also be performed on a vehicle with a vehicle status indicator.
Procedure
WARNING:
The cleaner (part # A 005 989 19 71) used in this service campaign contains isopropyl alcohol and ethyl acetate. It may be harmful in direct contact with eyes or ingested; vapors from the cleaner may irritate eyes and skin. In case of contact with eyes, rinse immediately with plenty of water, holding eyes open for at least 20 minutes, and seek medical advice. After contact with skin, wash immediately with soap or mild detergent and plenty of water. This material and its container must be disposed of in a safe way. Wear safety glasses with side protectors and butyl, neoprene, or nitrile gloves. Refer to the MSDS (via NetStar or the Parts Assistance Center website) for a complete description of these hazards and other important safety information.
1. Replace trunk lid handle strip (A, Figure 1); refer to WIS document AR88.50-P-5080TX.
Note regarding above WIS document:
The 100 mm eraser disc mentioned in the document is available as the Stripe Off Wheel from 3M(TM) (part number 07498; Figure 2). It should be procured from your local 3M(TM) jobber. Please make sure to use the product as described in the WIS document.
Special Tools
NOTE:
The above-noted special tools are classified as "K-" tools; they can be ordered at the discretion of the dealer.
Parts Information
NOTE:
- Please be aware that only the part number(s) referenced in the Campaign Bulletin is approved for use to repair the vehicle. Repairs performed using any other part(s) will not have been performed in accordance with the campaign. Accordingly, warranty claims submitted with reference to an improper part number(s) will be denied.
- The following allowable labor operation should be used when submitting a warranty claim for this repair:
Warranty Information
Operation:
Handle Strip at Trunk Lid, Replace (02-5324)