Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Factory Modifications
- Recommended Repairs
- Superceded Bulletins
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Replacement Plate/Label
- VIN - Master Decoder Information
- New Service Bulletin Group Numbers
- Recall - Headlights Fail to Illuminate
- VIN - Decoder
- VIN - Information Decoder
- VIN - Plate Location Update
- VIN - Master Decoder Chart
- VIN - Identification
- A/C - Installation Manual Supplement
- A/C - System Leak Checking
- A/C - Odor Correction
- A/C - Handling Precautions For Freon R-12
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Steering - Corrective Procedure For Pull or Drift
- Engine - Valve Noise at Start-up
- Fuel - System Diagnosis In Tank Filter Clogging
- Brakes - Pad Installation Service Points
- Brakes - Front Brake Judder
- Brakes - Rear Disc Squeak
- Spark Plug Gap - Manual Update
- Spark Plug - Fouling
- Steering - Seal Kit Reassembly Special Grease
- Campaign - Timing Belt Replacement
- Timing Belt - Improved Installation Procedure
- Engine - Revised Cylinder Head Bolt Torques
- Engine - Automatic Valve Lash Adjuster Noise
- Engine - Valve Lash Adjuster Cleaning Procedure
- Valve Lash Adjuster Noise - Troubleshooting Procedures
- Piston Pin - Installation Tool Instructions
- Engine - New Oil Pump May Reduce Noise
- Engine Oil Pump - Drive Gear Clearance Update
- Interior - Idle Vibration
- Engine - Piston Pin Installation Tool
- Tools - Piston Pin Tool Operating Instructions
- Piston Ring - End Gap Specification Change
- Timing Belt - Auto-Tensioner Improved
- A/C - Mode Selection Damper, Vinyl Sleeve
- Wheels - Vibration On Early Production Model
- Tires/Brakes - Vibration
- Wheel - Balancing Accuracy Tips
- Wheels - Lug Nut Torque Information and Chart
- Window - Door & Glass Adjustment
- Interior - Wind Noise Diagnosis
- Recall - Defective Sunroof Hinge Design
- Sunroof - Rattle Or Squeak
- Interior Trim - Repair Of Headliner Front Trim
- Steering - Removal of Column Shaft
- Drivetrain - Tripod Joint (TJ) On Driveshaft
- Clutch - Release Bearing Manual Correction
- Drivetrain - Rear Axle Pinion Height Adjustment
- Interior - Drivetrain Vibration
- Transfer Case - Cover Gasket Sealing
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- ECM - Adaptive Memory
- Engine Controls - Never Use a Test Light To Check an ECM
- Recall - Oxygen Sensor Replacement
- EGR - Temperature Sensor Inspection
- CV Joint Boot - Replacement Tool/Installation
- Drivetrain - Axle Hub End Play Manual Correction
- Battery - Care During Long Term Storage
- Battery - Application Guide/Cold Cranking Amp Specs.
- Turbocharger - Repair Kit Availability
- Power Window Motor - Manual Update
- Windows - Repair of Rear Defogger Grid
- Rear Window Defogger Grid - Repair
- Audio System - Speaker Static/Buzzing/Inoperative
- Brakes - Rotor Service Procedures
- M/T - Input Shaft Illustrations, Manual Corrections
- M/T - Input Shaft Change
- Engine - Block Heater Update
- Ignition - Timing Adjustment Revised
- Ignition - Timing Adjustment, Manual Change
- Oil Pressure Sending Unit - Two Units
- Lights - Left Headlight Does Not Retract
- Recall 89V128000: Headlamp Wire Harness Defect
- Headlight Center Garnish - Moisture Removal
- Cooling System - Torque Change For Temp Sensors
- Engine - Revised Cylinder Head Gasket Design
- Brakes - ABS Operation Characteristics
- Antilock Brake System - Diagnosis
- Interior - Diagnosis and Repair of Body Water Leaks
- Synthetic Resin Parts - Heat Resistance Specifications
- VIN - Codes
- Body - Noise Diagnosis
- Tools - Fault Codes When Using the Multi-Use Tester
- Antitheft - Security System Installation Procedures
- Antitheft - Power Door Lock Interface Module
- Emission - Control Information Label Ordering
- Emissions - Correct Diagnosis of Emission Control Parts
- Recall - Emission Control Label Replacement
- Engine Controls - DTC P0441
- Tools - MSN Multi-Use Tester ROM Pack Update
- Multi-Use Tester - Two Part Number Explanation
- Tools - Multi-Use Tester ROM Pack Usage
- Tools - Enhanced Diagnostic Testing & Feature Software
- Hard Start/No Start Condition - Cold/Hot
- Tools - Multi-Use Tester ROM Pack Usage
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Audio - Speaker Troubleshooting Manual Supplement
- Windshield - Installation Instructions
- Recall - Windshield Non Compliance
- Recall 90V106002: Dilluted Windshield Primer
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Cooling System - Water Outlet Fitting Gasket Change
- Brakes - Pedal Height Adjustment Manual Revision
- A/T - Specification Changes
- A/T - Rear Clutch Assembly, Manual Revision
- A/T End Clutch - Improved
- Automatic Transaxle - Improved Rear Clutch
- A/T - Gear Noise Reduction
- A/T - Repair Manual Correction, Reassembly
- A/T - Various Seals Manual Update
- Tools - New for Automatic Transaxle Repairs
- A/T - Service Manual Diagnostic Supplement
- A/T - Remanufacturing Program
- A/T - Remanufacturing Program.
- A/T, Remanufactured - Program Update
- Transmission - Identification Codes
- A/T - New End-Play and Preload Measurement
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Reverse Gear Noise Prevention Mechanism
- M/T - Prevention of Shifter Blocking
- M/T - Intermittent Rattle Noise, New Design Spring
- M/T - Flywheel Surfacing Limit
- Audio - CD Player Noise
- Suspension - Lower Control Arm Bolt Torque Specification
- A/C Switch - Installation Procedure Change
- Engine - Oil Economy Test
- Chemicals - Fuel Injector Cleaner Feels 1/2 Full
- Cruise Control - Updated Diagnostic Procedures
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Remote Keyless Entry - Update
- Radio - Poor Reception
- Body - Moisture In Front Turn Signals
- Seat Belts - Automatic Belt Clunking Noise
- Seat Belts - Operation of the Automatic Shoulder Belt
- Recall - Front Seat Belt Buckle
- Seatbelt - Reminder Light Blinking
- Interior Trim - Panel Replacement Clip
- Interior - Buzz, Squeak, and Rattle Kit
- Window - Chemical Film Build-Up/Fogging
- Recall 90V106000: Defective Windshield Primer
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Paint - Removing Etched Spots
- Paint - Color Codes
- Paint - Exterior Color Codes
- Paint - Damage Identification and Repair
- Recall 98V069000: Insufficient Transfer Case Lubrication
- M/T - Shift Cable Rattle Or Buzzing
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- M/T - Hard Shifting/Gear Clashing
- A/T - Differential Bearing Spacer Thickness Correction
- Recall 90V056002: Sunroof Hinge
- Recall 90V056000: Sunroof Hinge
- Sunroof - Wind Noise/Air Leak
- M/T - Fluid Recommendation/Caution
- Campaign - Incorrect Service Points Label
- Brakes - Judder (vibration) Diagnosis and Repair
- A/C - Refrigerant Temperature Switch Manual Correction
- Engine - Pinging Condition
- A/C - Refrigeration Oil Specification
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Alignment - Two Wheel Vs. Four Wheel
- Restraints - Revised SRS ECU Removal and Installation