Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Odor Correction
- Engine - Valve Noise at Start-up
- Spark Plug - Fouling
- Interior - Idle Vibration
- Window - Door & Glass Adjustment
- Overview
- Purpose, Vehicles Affected, And Materials Required
- Procedure A: Replacing Door Window Regulator
- Procedure B: Seating Rear Runchannel
- Procedure C: Adjusting Door To Body & Window To Rear Sash Frame
- Procedure D: Widening Front Window Track
- Procedure E: Window Regulator Adjustment
- Procedure F: Window Regulator To Door Adjustment
- Parts And Warranty Information
- Interior - Drivetrain Vibration
- Audio System - Speaker Static/Buzzing/Inoperative
- Horn - Sounds Too Low, Too High or No Sound
- A/T - Shift Delay Before Warm Up
- Radio - Poor Reception
- Window - Chemical Film Build-Up/Fogging
- Brakes - Judder (vibration) Diagnosis and Repair
- Recommended Repairs
- Superceded Bulletins
- 96-11-002 - 03/01/96
- 9423005 - 10/01/94
- 9423005 - 12/01/94
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Audio System - Diagnosis
- Remote Keyless Entry - Service Information
- Remanufactured Automatic Transmission - Program
- Cylinder Block - Heater Installation Procedure
- Engine Block Heater - Application and Installation
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Replacement Plate/Label
- VIN - Decoder
- Electrical - Manual Correction Table Of Contents Wrong
- VIN - Master Decoder
- A/C - System Leak Checking
- A/C - Odor Correction
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Engine - Valve Noise at Start-up
- Engine Controls - TPS Harness Inspection Revision
- Fuel - System Diagnosis In Tank Filter Clogging
- Fuel - Pump Volume Delivery Test
- Spark Plug - Fouling
- Engine - Head & Main Bolt, Rod Nut Torque Revision
- Engine - Revised Nut & Bolt Tightening Specifications
- Campaign - Timing Belt Replacement
- Engine - Timing Belt Installation Manual Revision
- Engine - Valve Lash Adjuster Cleaning Procedure
- Valve Lash Adjuster Noise - Troubleshooting Procedures
- Piston Pin - Installation Tool Instructions
- Interior - Idle Vibration
- Engine - Piston Ring Modification
- Engine - Piston Ring Installation Corrections
- Timing Belt Auto Tensioner - Testing
- Wheel - Balancing Accuracy Tips
- Wheels - Lug Nut Torque Information and Chart
- Window - Door & Glass Adjustment
- Overview
- Purpose, Vehicles Affected, And Materials Required
- Procedure A: Replacing Door Window Regulator
- Procedure B: Seating Rear Runchannel
- Procedure C: Adjusting Door To Body & Window To Rear Sash Frame
- Procedure D: Widening Front Window Track
- Procedure E: Window Regulator Adjustment
- Procedure F: Window Regulator To Door Adjustment
- Parts And Warranty Information
- Interior - Wind Noise Diagnosis
- Interior - Drivetrain Vibration
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- ECM - Adaptive Memory
- Engine Controls - Never Use a Test Light To Check an ECM
- CV Joint Boot - Replacement Tool/Installation
- Battery - Application Guide/Cold Cranking Amp Specs.
- Turbocharger - Repair Kit Availability
- Rear Window Defogger Grid - Repair
- Audio System - Speaker Static/Buzzing/Inoperative
- Air Bag - Minimizing Deployment Risk
- SRS - Diagnostic Trouble Code (DTC) Erasure
- Brakes - Rotor Service Procedures
- Engine - Block Heater Update
- Horn - Sounds Too Low, Too High or No Sound
- Engine - Minimum Oil Pressure Service Manual Revision
- Cooling System - Torque Change For Temp Sensors
- Engine - Revised Cylinder Head Gasket Design
- Brakes - Revised ABS Wiring Diagram
- Antilock Brake System - Diagnosis
- Payload/Gross Vehicle Weight Rating Information
- Synthetic Resin Parts - Heat Resistance Specifications
- Body - Noise Diagnosis
- Emission - Control Information Label Ordering
- Engine Controls - DTC P0441
- Tools - MSN Multi-Use Tester ROM Pack Update
- Tools - Multi-Use Tester-II Warranty
- Tools - Enhanced Diagnostic Testing & Feature Software
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T End Clutch - Improved
- Automatic Transaxle - Improved Rear Clutch
- A/T - Shift Delay Before Warm Up
- A/T - Remanufacturing Program
- A/T - Remanufacturing Program.
- A/T, Remanufactured - Program Update
- Transmission - Identification Codes
- A/T - New End-Play and Preload Measurement
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Flywheel Surfacing Limit
- Engine - Oil Economy Test
- Engine - Oil Consumption/Oil Economy Test
- Chemicals - Fuel Injector Cleaner Feels 1/2 Full
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Keyless Entry - System Availibility
- Remote Keyless Entry - Update
- Radio - Poor Reception
- Seat Belts - Operation of the Automatic Shoulder Belt
- Interior - Buzz, Squeak, and Rattle Kit
- Window - Chemical Film Build-Up/Fogging
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Paint - Exterior Color Code & Cross Reference
- Paint - Damage Identification and Repair
- Recall 98V069000: Insufficient Transfer Case Lubrication
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- M/T - Fluid Recommendation/Caution
- Brakes - Judder (vibration) Diagnosis and Repair
- A/C - Refrigerant Temperature Switch Manual Correction
- Engine - Pinging Condition
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Alignment - Two Wheel Vs. Four Wheel
- Engine - Lead Free Crankshaft Bearing Info. Revision
- Restraints - Revised SRS ECU Removal and Installation