Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Odor Correction
- Spark Plug - Fouling
- Interior - Idle Vibration
- Suspension - Rattle or Popping From Front
- Audio System - Speaker Static/Buzzing/Inoperative
- Horn - Sounds Too Low, Too High or No Sound
- Body - Roof Rack Fading and Paint Peeling
- A/T - Shift Delay Before Warm Up
- Window - Chemical Film Build-Up/Fogging
- Brakes - Judder (vibration) Diagnosis and Repair
- Recommended Repairs
- Superceded Bulletins
- 96-11-002 - 03/01/96
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Audio System - Diagnosis
- Remote Keyless Entry - Service Information
- Cylinder Block - Heater Installation Procedure
- Engine Block Heater - Application and Installation
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Replacement Plate/Label
- VIN - Decoder
- VIN - Master Decoder
- A/C - System Leak Checking
- A/C - Odor Correction
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Fuel - System Diagnosis In Tank Filter Clogging
- Fuel - Pump Volume Delivery Test
- Engine - Valve Clearance Manual Revision
- Spark Plug - Fouling
- Rear Wheel Bearing - Removal Revision
- P/S Gear Box - Oil Seal/Bearing Installation Tool
- Engine - Head & Main Bolt, Rod Nut Torque Revision
- Engine - Revised Nut & Bolt Tightening Specifications
- Engine - Valve Lash Adjuster Cleaning Procedure
- Valve Lash Adjuster Noise - Troubleshooting Procedures
- Piston Pin - Installation Tool Instructions
- Interior - Idle Vibration
- Engine - Piston Ring Installation Corrections
- Wheel - Balancing Accuracy Tips
- Suspension - Rattle or Popping From Front
- Wheels - Lug Nut Torque Information and Chart
- Power Window - Motor & Regulator Assembly Procedures
- Interior - Wind Noise Diagnosis
- Recall - Transfer Case Inspection and Repair.
- A/T - Oil Pressure Test Ports Service Manual Revision
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- ECM - Adaptive Memory
- Engine ECU Internal Circuit - Service Manual Revision
- Engine Controls - Never Use a Test Light To Check an ECM
- Drivetrain - Driveshaft Servicing
- CV Joint Boot - Replacement Tool/Installation
- Brake Booster - Push Rod Adjustment
- Battery - Application Guide/Cold Cranking Amp Specs.
- Rear Window Defogger Grid - Repair
- Audio System - Speaker Static/Buzzing/Inoperative
- Recall 97V063001: Shoulder Belt Problem
- Air Bag - Minimizing Deployment Risk
- SRS Air Bag Troubleshooting - Revision
- SRS Cautions and Warnings - Revision
- SRS - Diagnostic Trouble Code (DTC) Erasure
- Brakes - Rotor Service Procedures
- Brakes - Disc Run-Out Specification Limits
- Front Brakes - Disc Run Out Specifications Revision
- Engine - Block Heater Update
- Horn - Sounds Too Low, Too High or No Sound
- Engine - Minimum Oil Pressure Service Manual Revision
- Antilock Brake System - Diagnosis
- Antilock Braking System - Service Manual Revision
- Antilock Braking System - Manual Revision
- Payload/Gross Vehicle Weight Rating Information
- Synthetic Resin Parts - Heat Resistance Specifications
- Body - Noise Diagnosis
- Emission - Control Information Label Ordering
- Recall - Emission Control Label Replacement
- Engine Controls - DTC P0441
- Tools - MSN Multi-Use Tester ROM Pack Update
- Tools - Multi-Use Tester-II Warranty
- Tools - Enhanced Diagnostic Testing & Feature Software
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Body - Roof Rack Fading and Paint Peeling
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T End Clutch - Improved
- Automatic Transaxle - Improved Rear Clutch
- A/T - Oil Pressure Testing Service Manual Revision
- A/T - Cold Delay Shift
- A/T - Shift Delay Before Warm Up
- A/T - Remanufacturing Program.
- A/T, Remanufactured - Program Update
- Transmission - Identification Codes
- A/T - New End-Play and Preload Measurement
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Third Gear Limp-in Condition
- A/T - Alternative Method to Retrieve Codes
- A/T - KM175 Delayed Forward Engagement
- A/T - KM175 Harsh Downshifts
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - KM175 Series 1-2 Bind Up
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- A/T - Third Gear Starts
- M/T - Flywheel Surfacing Limit
- Idle Switch Inspection - Service Manual Revision
- Engine - Oil Economy Test
- Engine - Oil Consumption/Oil Economy Test
- Chemicals - Fuel Injector Cleaner Feels 1/2 Full
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Keyless Entry - System Availibility
- Remote Keyless Entry - Update
- Seat Belts - Operation of the Automatic Shoulder Belt
- Recall - Automatic Shoulder Belt Door Latch Switch
- Automatic Transaxle - Shift Characteristics of F4A
- Interior - Buzz, Squeak, and Rattle Kit
- Recall 97V0630001: Door Latch Switch Malfunction
- Recall 97V063000: Door Latch Switch Malfunction
- Window - Chemical Film Build-Up/Fogging
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Paint - Exterior Color Code & Cross Reference
- Paint - Damage Identification and Repair
- Fuel Tank - Drain Plug Washer and Torque Revision
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- Recall 98V168000: Transfer Case Oil Low/Leak
- M/T Shift Lever - Operational Inspection Revision
- M/T - Fluid Recommendation/Caution
- Brakes - Judder (vibration) Diagnosis and Repair
- A/C - Refrigerant Temperature Switch Manual Correction
- Engine - Pinging Condition
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Alignment - Two Wheel Vs. Four Wheel
- Restraints - Revised SRS ECU Removal and Installation