Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Safety
- Recall 00V225001: Possible Steering Defect
- Recall 99V305001: Steering Column Switch Levers Defect
- Recall - A/T Cooler Line Replacement
- Recall 01V011001: Transaxle Oil Cooler Hose Defect
- Recall 99V333001: Battery Cable Harness Problem
- Recall - Column Switches for Lights/Wiper
- Recall - Replace Power Steering Rack Oil Feed Tube
- Recall - Loose Steering Pinion Gear Lock Nut
- Customer Interest
- Audio System/A/C Blower - Intermittent Operation
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- Engine Controls - Rough Idle/DTC's P0300-P0306
- A/C - Musty/Moldy Odors In Passenger Compartment
- Rear Wheel Bearing - Noise
- Engine Controls - Hard Hot Start/Rough Idle
- Door/Glass - Wind Noise/Water Leaks/High Closing Effort
- Starting - Intermittent No Crank/No Start
- Speakers - Popping Noise During Seat Switch Operation
- Audio System - Speaker Static/Buzzing/Inoperative
- Lighting - Headlamp Lens Fogging
- Front Stabilizer Bushings - Creaking/Popping Noise
- Antitheft - Procedure For No Start Problem
- Fuel/Emissions - Sulfur Odor From Exhaust
- Body - Liftgate Half-Latching Condition
- Door Window - Musty Odor
- Sunroof - Judder/Vibration During Operation
- Body - Sunroof Judder/Vibration
- Body - Water Leak to Interior From Mirror Trim
- Engine - Overheating/Low Coolant Level/Noise
- A/T - 2-3 Shift Flare/Slipping
- Antitheft - Remote Keyless Entry Intermittent Operation
- Audio System - Static/Popping/Poor Sound/Distortion
- A/C - Water Leaks to The Interior
- Interior - Difficult Front Seat Sliding Effort
- Brakes - Judder (vibration) Diagnosis and Repair
- Side Air Bag Module - DTC 72 or 82 Set
- Electrical - Radio/Dome Lamp/Keyless Entry Inoperative
- Recommended Repairs
- Superceded Bulletins
- 05-23-004R - 08/01/05
- 99-00-003 - 06/01/99
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- 01-00-011 - 07/01/01
- 00-42A-002 - 04/01/00
- Door Window - Odor
- Door Window - Wind Noise/Water Leaks
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Sunroof - Judder/Vibration
- Sunroof - Judder/Vibration On Operation
- Body - Bumper Facia Preparation for Painting
- Audio System - Diagnosis
- Antitheft - Engine Immobilizer System PDI & Service
- Remote Keyless Entry - Service Information
- Keyless Entry - ID Mode Canceling Conditions Revision
- Recall - Steering Gear Pinion Lock Nut Loose
- A/T - Shudder/Surge/Vibration
- A/T - 2-3 Shift Flare
- Engine Controls - Hard Hot Restart/Rough Idle/DTC's Set
- Scan Tool - Warranty Coverage/Repair Return Procedures
- Engine - Testing for Excessive Oil Consumption
- Engine - Oil Economy Test/Consumption Diagnosis
- Cylinder Block - Heater Installation Procedure
- Tires/wheels - Tire Chain Usage Information
- Radio/Electronics - Intermittent Loss of Power
- A/C - Receiver Outlet Pipe Replacement
- A/C - Water Leaks Into The Passenger Compartment
- Engine Controls - Hard Hot Re-Start/Rough Idle
- Engine Controls - Cold Engine Misfire Condition
- Engine Controls - Cold Engine Misfire
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Restraints - SRS Component Disposal Information
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Body - Bumper Fascia/Plastic Fender Paint Preparation
- Vehicle - Load Capacity Reduction Label Information
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- Audio System/A/C Blower - Intermittent Operation
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- VIN - Decoding Chart
- Tool - Battery/Starting/Charging System Analyzer
- Audio System - No Radio/Audio Controls Locked-Up
- Engine Controls - Rough Idle/DTC's P0300-P0306
- A/C Magnetic Clutch - Corrected Service Procedures
- A/C - Musty/Moldy Odors In Passenger Compartment
- Rear Wheel Bearing - Noise
- Recall 00V225001: Possible Steering Defect
- Engine - Valve Lash Adjuster Cleaning Procedure
- Engine - Replacement Piston Selection
- Engine Controls - Hard Hot Start/Rough Idle
- Suspension - Ball Joint End Play Procedure Revision
- Tire Chains - Usage Precautions
- Wheel - Balancing Accuracy Tips
- Tires - Updated Rotation Recommendations
- Tires - Goodyear(R) Product Service Locations
- Door/Glass - Wind Noise/Water Leaks/High Closing Effort
- Interior - Wind Noise Diagnosis
- Vehicle - Aftermarket Accessories Precautions
- Sunroof - Changed Sunroof Water Test
- Recall 99V305001: Steering Column Switch Levers Defect
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Recall - A/T Cooler Line Replacement
- Recall 01V011001: Transaxle Oil Cooler Hose Defect
- Engine Controls - PCM Reprogramming Procedure
- Battery - Application Guide/Cold Cranking Amp Specs.
- Recall 99V333001: Battery Cable Harness Problem
- Starting - Intermittent No Crank/No Start
- Recall - Emissions Vacuum Hose Routing Label
- Speakers - Popping Noise During Seat Switch Operation
- Audio System - Speaker Static/Buzzing/Inoperative
- Air Bag - Minimizing Deployment Risk
- Engine - Block Heater Update
- Headlights - Shutdown Time Revision
- Lighting - Headlamp Lens Fogging
- Recall - Column Switches for Lights/Wiper
- A/C - Refrigerant Pipe Replacement
- ABS - DTC 15 Revised Diagnostic Procedures
- TCL Solenoid Valve - Service Manual Corrections
- Brakes/Emissions - I/M Dynometer Testing on TCL Models
- Front Stabilizer Bushings - Creaking/Popping Noise
- Payload/Gross Vehicle Weight Rating Information
- Body - Noise Diagnosis
- Antitheft - Starting Using Immobilizer Override Function
- Antitheft - Immobilizer Override Codes Missing
- Antitheft - Procedure For No Start Problem
- Antitheft - Immobilizer System Service Information
- Engine Controls - Revised Vacuum Routing Diagrams
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls/Emissions - OBDII Drive Cycle Revisions
- Engine Controls - DTC P0441
- Tools - Enhanced Diagnostic Testing & Feature Software
- Scan Tool - Multi-Use Tester II Warranty Coverage
- Engine Controls - SCAN Tool Display Term Changes
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Body - Liftgate Half-Latching Condition
- Door Window - Musty Odor
- Sunroof - Judder/Vibration During Operation
- Body - Sunroof Judder/Vibration
- Wipers/Washers - Wiper Nut Torque Revisions
- Body - Water Leak to Interior From Mirror Trim
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Engine - Overheating/Low Coolant Level/Noise
- Recall - Replace Power Steering Rack Oil Feed Tube
- A/T - 2-3 Shift Flare/Slipping
- A/T, Remanufactured - Program Update
- A/T - Recommended Maintenance
- A/T - Revised Bolt Torque Values
- A/T - New End-Play and Preload Measurement
- Manual Transaxle - Removal Procedure Revision
- Audio System - CD Player Functional Problems
- Antitheft - Remote Keyless Entry Intermittent Operation
- Heating, A/C - Mode/Temperature Control Parts
- A/T - No Overdrive/Shift Delay
- A/C - Service Manual Revisions
- Engine - Oil Consumption/Oil Economy Test
- Cruise Control - Troubleshooting Instructions
- Cruise Control - Revised Checking Procedures
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Remote Keyless Entry - Update
- Remote Keyless Entry - Identification/Programming
- Keyless Entry - Revised Answerback Function Information
- Keyless Entry - ID Mode Canceling Conditions Update
- Keyless Entry - Answerback Switching Procedures Revision
- Interior - Buzz, Squeak, and Rattle Kit
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Audio System - Static/Popping/Poor Sound/Distortion
- Paint - Color Codes/Applications
- A/C - Water Leaks to The Interior
- A/C - Compressor Pressure Relief Valve Service
- A/C - Compressor Pressure Relief Valve Service Revisions
- Interior - Difficult Front Seat Sliding Effort
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- Recall - Loose Steering Pinion Gear Lock Nut
- A/C Drain Hose - Service Manual Correction
- Brakes - Judder (vibration) Diagnosis and Repair
- Fuel System - Tank Pressure Sensor Specification Update
- Entertainment Device - CD Changer Installation
- Engine - Pinging Condition
- Interior - Child Seat Additional Upper Tether Anchor
- Side Air Bag Module - DTC 72 or 82 Set
- A/C - Water On Passenger's Side Floor
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Brakes - Master Cylinder Service Revision
- Electrical - Radio/Dome Lamp/Keyless Entry Inoperative
- Body - Bumper Fascia Painting Preparation
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Powertrain - DTC P0335 & P0340 After Engine Repair
- Powertrain, Antitheft - ECU & PCM Replacement
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Powertrain - DTC's P0335 & P0340 After Engine Repair
- Alignment - Two Wheel Vs. Four Wheel
- Engine Controls - Revised Misfire DTC Information
- Body - Revised Door Adjustment Procedure
- Restraints - Revised SRS ECU Removal and Installation