Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Poor Heater Performance in Extreme Cold
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- Brakes - Front Brake Clicking/Squealing/Groaning Noises
- A/C - Musty/Moldy Odors In Passenger Compartment
- M/T - Rattling Noise Idling in Neutral
- Engine Controls - MIL ON/DTC P0507 Set
- Audio System - Speaker Static/Buzzing/Inoperative
- Suspension - Squeak From Rear of Vehicle While Driving
- Interior - Water Leaks Onto The Front Floorboard Area
- Fuel/Emissions - Sulfur Odor From Exhaust
- Body - Creaking Noise from Windshield/A-Pillar Area
- Cooling System - Upper/Lower Radiator Hose Collapsed
- A/T - 2-3 Shift Flare/Slipping
- A/C - Temperature Knob Hard to Turn
- Audio System - Static/Popping/Poor Sound/Distortion
- A/C - Water Leaks to The Interior
- Engine Controls - Hard/No Start/DTC P0335 or P0340 Set
- Superceded Bulletins
- EMR05-001 - 08/01/05
- 05-23-004R - 08/01/05
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- 01-00-009R - 12/01/01
- VIN - Decoding Chart
- Lighting - Moisture In Headlamps
- Keyless Entry - ID Mode Canceling Conditions Revision
- A/C - Heater Control Dial Hard to Turn
- Suspension - Revised Rear Lower Control Arm Bushing Svc.
- PCM - DTC P0507 Set/MIL ON
- A/T - 2-3 Shift Flare
- Recall - ECM Reprogram/Cat Converter Warranty Extension
- Engine - Testing for Excessive Oil Consumption
- Engine - Oil Economy Test/Consumption Diagnosis
- A/C - Water Leaks Into The Passenger Compartment
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Restraints - SRS Component Disposal Information
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Load Capacity Reduction Label Information
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Vehicle Identification Number - New Model Revisions
- General Specifications
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- A/C - Poor Heater Performance in Extreme Cold
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- Recall - Throttle Position Sensor Re-Learn for High Idle
- Brakes - Front Brake Clicking/Squealing/Groaning Noises
- A/C - Musty/Moldy Odors In Passenger Compartment
- Engine - Valve Lash Adjuster Cleaning Procedure
- Engine - Replacement Piston Selection
- Tires - Goodyear(R) Product Service Locations
- Tire Chain - Usage Recommendations
- Rear Spoiler - Removal/Installation Revision
- Vehicle - Aftermarket Accessories Precautions
- M/T - Rattling Noise Idling in Neutral
- ECM/PCM - Service Manual Corrections
- Engine Controls - PCM Reprogramming Procedure
- Battery - Application Guide/Cold Cranking Amp Specs.
- Battery - Load Test Rate Chart Revision
- Alternator - FR Terminal Voltage Revision
- Engine Controls - MIL ON/DTC P0507 Set
- Recall - PCM Update for Warm-Up Cat. Converter Melt Down
- Engine - Poor High RPM Acceleration
- Audio System - Speaker Static/Buzzing/Inoperative
- Engine Block Heaters - Usage
- Wiper/Washer - Switch Checking Procedure Correction
- Suspension - Squeak From Rear of Vehicle While Driving
- Suspension - Revised Rear Lower Arm Bushing Replacement
- Body Welded Panel - Replacement Method Revision
- Body Dimensions - Manual Revision
- Interior - Water Leaks Onto The Front Floorboard Area
- Body - Noise Diagnosis
- Body - Partial Welded Panel Replacement
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls/Emissions - OBDII Drive Cycle Revisions
- Engine Controls - DTC P0441
- EVAP System - DTCP0441 Manual Update
- Engine Controls - SCAN Tool Display Term Changes
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Fuel System - DTC P0181 Update
- Interior - Door Panel Vibration Noise
- Body - Trunk Lid Adjustment/Torsion Bar Removal
- Body - Creaking Noise from Windshield/A-Pillar Area
- Body - A Pillar Rattling/Clicking Noise
- Wipers/Washers - Wiper Nut Torque Revisions
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Cooling System - Specified Engine Coolant Revision
- Cooling System - Radiator Hose Collapsed
- Cooling System - Upper/Lower Radiator Hose Collapsed
- A/T - 2-3 Shift Flare/Slipping
- A/T - Revised Bolt Torque Values
- A/T - Hydraulic Pressure Manual Update
- A/T - New End-Play and Preload Measurement
- Audio System - CD Player Functional Problems
- A/C - Inoperative/A/C Light Blinks
- A/C - Temperature Knob Hard to Turn
- A/T - No Overdrive/Shift Delay
- Instruments - Speedometer is Inoperative
- Campaign - Cooling Fan Controller Replacement
- Engine - Oil Consumption/Oil Economy Test
- Cruise Control - Diagnostics Revisions
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Remote Keyless Entry - Description/Operation
- Keyless Entry - Revised Answerback Function Information
- Keyless Entry - ID Mode Canceling Conditions Update
- Keyless Entry - Answerback Switching Procedures Revision
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Audio System - Static/Popping/Poor Sound/Distortion
- Paint - Exterior Color Codes and Applications
- Fuel Tank Filler Valve Flap - Elimination
- A/C - Water Leaks to The Interior
- A/C - Compressor Pressure Relief Valve Service
- Brake Booster Push Rod - Specification Correction
- Antitheft - Registration Of Additional Immobilizer Keys
- License Plate Mounting - Manual Addition
- Fuel System - Tank Pressure Sensor Specification Update
- Engine - Pinging Condition
- M/T, Fuel - Accelerator/Clutch Pedal Stopper Revision
- Instruments - Odometer Reset After Replacing Speedometer
- Engine Controls - Hard/No Start/DTC P0335 or P0340 Set
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Steering - Revised Tie Rod Free Play Inspection
- Body/Frame - Corrosion Inhibitor Information
- Brakes - Parking Brake Lever Lock Nut Revision
- Suspension - Corrected Front Strut Mounting Bolt Torque
- Brakes - Revised ABS Hydraulic Unit Torque Specification
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Engine Controls - ECM Programming Precaution
- Powertrain, Antitheft - ECU & PCM Replacement
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine Controls - Revised Misfire DTC Information
- M/T - Revised Shift Cable Installation Procedure
- Body - Revised Door Adjustment Procedure
- Restraints - Revised SRS ECU Removal and Installation