Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Customer Interest
- A/C - Poor Heater Performance in Extreme Cold
- M/T - Rattling Noise Idling in Neutral
- Audio System - Speaker Static/Buzzing/Inoperative
- Suspension - Squeak From Rear of Vehicle While Driving
- Body - Creaking Noise from Windshield/A-Pillar Area
- Cooling System - Upper/Lower Radiator Hose Collapsed
- A/T - 2-3 Shift Flare/Slipping
- A/C - Temperature Knob Hard to Turn
- Audio System - Radio Comes ON Suddenly By Itself
- Audio System - Static/Popping/Poor Sound/Distortion
- Brakes - Noise Upon Light Application
- Engine Controls - False MIL ON/DTC's P0335/P0340
- Superceded Bulletins
- 05-23-004R - 08/01/05
- 05-54-002 - 02/01/04
- Lighting - Moisture In Headlamps
- Body - Color Codes
- Antitheft - Updated Service Information
- Keyless Entry System - Description/Operation
- Keyless Entry - ID Mode Canceling Conditions Revision
- Suspension - Revised Rear Lower Control Arm Bushing Svc.
- Engine Controls - False MIL/DTC's P2100/P2138/P0736
- A/T - 2-3 Shift Flare
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Restraints - SRS Component Disposal Information
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Load Capacity Reduction Label Information
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- A/C - Poor Heater Performance in Extreme Cold
- Engine - Valve Lash Adjuster Cleaning Procedure
- Engine - Valve Lifter Noise Diagnosis
- Engine - Bolt Locations
- Engine - Oil Pan Bolts
- Tires - Tire Pressure Specifications
- Vehicle - Aftermarket Accessories Precautions
- M/T - Rattling Noise Idling in Neutral
- Battery - Load Test Rate Chart Revision
- Alternator - FR Terminal Voltage Revision
- Engine - Poor High RPM Acceleration
- Audio System - Speaker Static/Buzzing/Inoperative
- Brakes - Revised Specifications
- Engine/Cooling System - Block Heater Installation
- Suspension - Squeak From Rear of Vehicle While Driving
- Suspension - Revised Rear Lower Arm Bushing Replacement
- Body - Noise Diagnosis
- Engine Controls/Emissions - OBDII Drive Cycle Revisions
- Engine Controls - DTC P0441
- Engine - Rattling Noise on Cold Start
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Fuel System - DTC P0181 Update
- Engine Controls - Freeze Frame Data For DTC's
- Interior - Door Panel Vibration Noise
- Body - Creaking Noise from Windshield/A-Pillar Area
- Body - A Pillar Rattling/Clicking Noise
- Engine - Oil Recommendations
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Cooling System - Radiator Hose Collapsed
- Cooling System - Collapsed Upper Radiator Hose
- Cooling System - Upper/Lower Radiator Hose Collapsed
- A/T - 2-3 Shift Flare/Slipping
- A/T - New End-Play and Preload Measurement
- A/C - Inoperative/A/C Light Blinks
- A/C - Temperature Knob Hard to Turn
- A/T - No Overdrive/Shift Delay
- Instruments - Speedometer is Inoperative
- Cruise Control - Diagnostics Revisions
- Tires/Wheels - Tire Chain Usage
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Keyless Entry - Description/Operation
- Keyless Entry - ID Mode Canceling Conditions Update
- Keyless Entry - Answerback Switching Procedures Revision
- Body - Wind Buffeting
- Audio System - Radio Comes ON Suddenly By Itself
- Audio System - Static/Popping/Poor Sound/Distortion
- Paint - Paint Codes
- Electronic Throttle Valve (ETV) - Initialization
- A/C - Compressor Pressure Relief Valve Service
- M/T - Revised Synchronizer Installation Procedures
- A/C - Cabin Filter Service Tip
- Engine - Pinging Condition
- Brakes - Noise Upon Light Application
- M/T, Fuel - Accelerator/Clutch Pedal Stopper Revision
- Engine Controls - False MIL ON/DTC's P0335/P0340
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- Body - Corrected Sunroof Initialization Procedures
- Interior - Rev. Front Door Interior Trim Core & Tube R&I
- Engine - Cylinder Head Oil Accumulator Elimination
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Steering - Revised Tie Rod Free Play Inspection
- Body/Frame - Corrosion Inhibitor Information
- Brakes - Parking Brake Lever Lock Nut Revision
- Suspension - Corrected Front Strut Mounting Bolt Torque
- Brakes - Revised ABS Hydraulic Unit Torque Specification
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Engine Controls - ECM Programming Precaution
- Powertrain, Antitheft - ECU & PCM Replacement
- Lighting - Headlamp Moisture Information
- Powertrain - Freeze Frame Data & MFI Related DTC's
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine - Lead Free Crankshaft Bearing Info. Revision
- Engine Controls - Revised Misfire DTC Information
- M/T - Revised Shift Cable Installation Procedure
- Body - Revised Door Adjustment Procedure
- Restraints - Revised SRS ECU Removal and Installation