Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Interior - Eliminating Unwanted Odors in Vehicles
- Body - Broken Rear Window Defogger Grid Detection
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Restraints - Seat Belt Latching Issues/Warning Lights
- A/C - Musty Odors Emitted From (HVAC) System
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Engine - Surge/Hesitation/Stumbles
- Engine - Hesitation or Sag On Hard Acceleration
- Engine - Hesitation or Sag Under Hard Acceleration
- Emissions - Reduced Performance Or Sag
- Rocker Cover Gasket - Oil Leaks
- Engine - Surge, Hesitation, Stumble on Hot Soak Restart
- A/C System - Delivers Air to Defroster Outlets Only
- Suspension - Chassis Spring Shims
- Wheels - Cast Aluminum Wheel Porosity Repairs
- Aluminum Wheels - Clear Coat Scuffed and Scratched
- P/S Cooler Line - Leaks
- Tires - Uneven Outer Edge Wear
- Doors - Squeaking Noises
- Door Lock Knob - Falls Off of Lock Rod
- Door - Glass to Weatherstrip Squeaking
- T-Top - Water Leaks to Interior
- Rear Compartment - Water Leaks
- M/T - Clutch Chatter, Driveline Disturbance
- Oil Pan Gasket - Revised to Eliminate Fluid Leaks
- A/T - Oil Pan Leaks
- A/T - 3rd-2nd, 2nd-1st Gear Coastdown Clunk
- A/T - Low Oil Pressure or Oil Pump Cavitation Noise
- A/T - Pump Noise
- ECM - Failures
- A/T Oil Pump Case Bolt - Leaks
- A/T - Fluid Leaks from Oil Pump Body
- A/T - No Drive and Reverse
- A/T Oil Pump Seal Assembly - Leaking
- A/T - Whine Noise In First, Second and Reverse
- A/T - Fluid Exhausting Out the Vent Pipe
- A/T - Oil Exhausting Out of the Breather
- M/T Speedometer Driven Gear Sleeve - Leaks
- A/T - Oil Leak Diagnosis
- A/T - Firm or Harsh 1-2 Shift
- A/T - Shift Comments T.V. Cable Adjusting Won't Correct
- Oxygen Sensor - Code 13 Set/MIL ON
- Brake Pedal - High Operating Effort
- Brakes - Parking Brake Service Adjustment Procedure
- Brakes - Rear Calipers Not Adjusting
- Battery - Low or Dead Overnight or 2-3 Days
- Battery/Charging System - No Start Condition
- Alternator Belt - Coming Off, Worn, Glazed or Broken
- Charging System - Abnormal Operation
- Engine - Surging After a Hot Soak
- Engine - Poor Driveability After Starting a Hot Soak
- Engine - Hesitation on Light Acceleration
- Engine - Rough Idle/Rich Acceleration/Lean Idle
- Power Antenna Mast - No AM Reception With Replacement
- Cellular - Telephone Service Program
- Turn Signal Lever - Rattles
- Engine - Miss, Hesitation, or Roughness
- Engine - Power Loss, Hesitation, Roughness/Backfire
- Engine - Summary of Warm Ambient Driveability Problems
- Starter Motor - Solenoid Clicks, Pinion Fails to Engage
- A/T - Overheating When Driven in Fourth Gear
- A/T - Early TCC Engagement, Stumble, Detonation
- Brakes - Drag Condition, Adjustment of Brake Switch
- Pulse-Wiper - Spontaneous Operation
- Accessory Drive Belts - Break/Coming Off Pulleys
- Suspension - Squawking Noise From Rear
- Body - Aftermarket Equipment, Sheet Metal Corrosion
- Engine Compartment - Water Entry
- Choke Light - Stays On
- Windshield Wiper Arm - Revision to Reduce Chatter
- T-Top and Roof Area - Water Leaks
- T-Top - Water Leaks
- Twin Lift-Off Panel - Water Leaks
- Rear Deck Luggage Carrier, A and J - Coming Loose
- Water Pump Gasket - Leak
- Wheels - Wire Wheel Cover Noise
- A/T - Burned 3-4 Clutch/High 2-3 Shifts
- A/T - Slipping/Premature Clutch Wear
- A/T - Slipping During 1-2 or 3-4, No 1-2 or 3-4 Upshift
- A/T - No Reverse or Slipping Reverse
- A/T - 4L60 Slipping or No 3rd/4th Gear
- A/T - Slipping or Loss of Drive Range
- A/T - Burned 3-4 Clutch Diagnosis
- A/T - 2ND or 3RD Gear Starts
- A/T - Diagnosing Oil Leaks
- A/T - Fluid Leaks from Fill Tube
- M/T - Harsh Manual 2-1 Downshift/Delayed Downshifts
- A/T - No 2ND, 4TH or Reverse Gear Operation
- M/T - Gear Clash Shifting to 3rd or 4th Gear
- M/T - Neutral/Drive Gear Rattle
- Compact Disc Players - CD Changer Loading Procedures
- SIR - Operating Vehicle with Warning Light On
- A.I.R. Pump Pulley - Rattling Noise
- Engine - Stops Running Due to TCC Engagement
- Engine - Hard Start/Poor Warm Up Performance
- Instrument Panel - Upper Surface Reflection
- Engine - Poor Idle Caused by Vacuum Leaks
- Speedometer Driven Gear Sleeve - Oil Leak
- Carpet - Loose on Side Wall Trim Pads
- A/T - 4L60 Binding or Inoperative In Reverse
- A/T - Reverse Gear Tie Up
- A/T - THM 200/200C Erratic Shift Patterns
- A/T - Erratic or No Upshift (Governor Drive Gear)
- A/T - Erratic or No Upshift
- A/T - Erratic or No Upshifts
- A/T - 4L60 Stuck In First Gear
- A/T - No Fourth Gear/Burned 2-4 Band Assembly
- M/T - Gear Clash
- P/S - Reduced Assist When Cold
- P/S - Proper Fluid Usage, Not ATF
- Power Steering - Reduced Assist At Low Temperatures
- Brakes, Front - Pulsation Diagnosis, Correction, Repair
- A/T- Grinding Noise In All Ranges/No Drive Condition
- Front Seat Back - Noisy
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- A/T - No Movement in Drive or 3rd Gear
- Body - Marks/Stains on Windshield When Wet
- Body - Stain/Film On Windshield Glass Perimeter
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Electrical - Intermittent MIL/DTC P2138/Reduced Power
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Body - Cracks In Left Motor Compartment Side Rails
- Interior - Eliminating Unwanted Odors in Vehicles
- Locks - Key Code Security Rules, Key Code Look Up
- Vehicle - Engine And Sub Systems Flushing Info. (CANADA)
- Vehicle - Engine And Sub-Systems Flushing Recommendations
- Wheels/Tires - Use Of Nitrogen Gas In Tires
- Tires - Information On Proper Tire Pressure
- Engine - THIS BULLETIN HAS BEEN CANCELED
- Fuel System - TOP TIER Detergent Gasoline
- Tires/Wheels - OE Tire Shake/Vibration Information
- Suspension - Shock Absorber/Strut Fluid Leak Information
- M/T - Operating Characteristics Information
- Brakes - Resurfacing Park Brake Portion of Rear Brake Rotor
- Body - Hem Flange Sealer For Corrosion Protection
- Engine - Intake Manifold Inspection/Replacement
- Body - Metal Body Panel Corrosion Protection
- Fuel System - GM Fuel System Treatment PLUS(R) Info.
- Body - Broken Rear Window Defogger Grid Detection
- Fuel System - Fuel Injector Maintenance Cleaning
- Audio - Inadvertent Steering Wheel Button Activation
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- A/T - Fluid Oil Cooler Flow Test
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Lighting - Lamp Polycarbonate Lens Damage Prevention
- Restraints - Seat Belt Latching Issues/Warning Lights
- Body - Side Window Chipping Information
- Restraints - Driver/Passenger Seat Head Rest Information
- Engine - Use of 'Surface Conditioning Disks'
- Body - Application of Anti-Corrosion Materials
- A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
- A/C - Musty Odors Emitted From (HVAC) System
- A/T - Slight Vehicle Movement In Park At Start Up
- A/T - DEXRON(R)-VI Fluid Information
- Wheels/Tires - Refinishing Aluminum Wheels
- Lighting - Exterior Lamp Condensation and Replacement
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Steering/Suspension - Wheel Alignment Specifications
- Warranty - Claims Submission
- Electrical Systems - Isolation Diode Replacement
- Warranty - Goodwrench Service Lifetime Service Guarantee
- Warranty - GM Dealer Parts Procurement
- Warranty - Notice of Delayed Start Process
- Warranty - Parts Warranty Special Claims B and C
- Warranty - Request for Wholesale Authorization
- VIN Plate - Replacement Policy and Procedure
- Warranty - GM Dealer Empowerment Program
- Labor - Revised Operation Z1241/Personal Property Damage
- Warranty - Repair/Replace Policies & Procedures
- Parts Expediting - Reimbursement Policy
- Warranty - Enhanced Sublet Repair Policy
- Warranty - Required Claim Submission Procedures
- Warranty - Repair and Claims Procedures
- Warranty - Claim Processing
- Warranty - Claims Processing
- Warranty - Corporate Parts Return Program Instructions
- Vehicle - Use of a Diagnostic Worksheet
- Vehicle - AC Delco Locator Service, Electronics Exchange
- Cooling Fan/Idle Speed/Spark Control - Electrical Tests
- Campaign - Product Bulletin Numbering System
- Vehicle - Past Model Warranty Claims Processing
- Parts - Expediting Procedures
- Glass - Adhesive Caulking Kit Revisions
- Electrical - Detecting Intermittent Problems
- Warranty - Corporate Parts Return Program
- Body - Daytona Pace Car Component Service Procedures
- I/M 240 Repairs - Obtaining Technical Assistance
- Electrical - Instrument Panel And General Wiring Repair
- A/C - Leak Test
- A/C - CFC Reduction & Refrigerant Recovery/Recycling
- A/C Refrigerant - Contamination
- A/C - Use of Alternate Refrigerants to R-12
- Tools - A/C Leak Detector Maintenance Kit Availability
- A/C - Systems With R12 Or R134a Service Issue
- A/C - Tool And Equipment Maintenance
- A/C - PureGuard 2 Operating Alert
- A/T & M/T - AC Delco Remanufactured Transmissions
- ACDelco(R) Remanufactured Transmissions - Program Update
- Engine - Oil Economy Information
- A/T - RTV Sealant Usage Precaution
- Engines - ACDelco Remanufactured
- Engine - Surface Conditioning Discs Precautions
- Engine - AC Delco Remanufactured Engines
- Engine - Effects of Top Engine Cleaner on the Converter
- Cooling System - Leak Diagnostic Procedure
- Engine - Surge/Hesitation/Stumbles
- Engine Controls - TPS Specifications
- Steering - System Bleed Procedures
- Fuel - Normal Pump Run-On
- Engine - Hesitation or Sag On Hard Acceleration
- Electric Fuel Pump - Wiring Diagrams
- Engine - Hesitation or Sag Under Hard Acceleration
- Disc Brake - Surface Refinishing Guidelines
- Emissions - Reduced Performance Or Sag
- Ignition - Spark Plug Application & Gap
- A/C Compressor Seal Washer - Reference Chart
- Suspension - Shock Absorber/Strut Replacement Guidlines
- Rocker Cover Gasket - Oil Leaks
- Engine - Surge, Hesitation, Stumble on Hot Soak Restart
- Cooling - Radiator Repair/Replacement Guidelines
- A/C System - Delivers Air to Defroster Outlets Only
- Manifold Bolt - Installation
- Engine/Transmission - Oil Cooler Diagnosis
- Suspension - Chassis Spring Shims
- Wheels (Steel) - Proper Changing Procedure
- Wheels - Cast Aluminum Wheel Porosity Repairs
- Wheels (Aluminum) - Coated Balance Weight Usage
- Aluminum Wheels - Clear Coat Scuffed and Scratched
- Warranty - OE Chrome Plated Aluminum Wheel ID
- Wheels - Measuring Wheel Runout
- P/S Cooler Line - Leaks
- Tires - Information On Refilling CO2 Tire Inflators
- Warranty - Tire Company Warranty Assistance Programs
- Tires - Uneven Outer Edge Wear
- Tires - Speed Rated Information
- Doors - Squeaking Noises
- Bumper Mounted Trailer Hitches - Information
- Door Lock Knob - Falls Off of Lock Rod
- Tires - Temporary Use Spares
- Door - Glass to Weatherstrip Squeaking
- T-Top - Water Leaks to Interior
- Rear Compartment - Water Leaks
- M/T - Clutch Chatter, Driveline Disturbance
- Oil Pan Gasket - Revised to Eliminate Fluid Leaks
- A/T - Oil Pan Leaks
- Differential Case Pinion Cross Shaft - Removal Procedure
- Differential Pinion Shaft Locking Screw - Revised
- A/T - 3rd-2nd, 2nd-1st Gear Coastdown Clunk
- A/T - Low Oil Pressure or Oil Pump Cavitation Noise
- A/T - Pump Noise
- A/T TCC Solenoid - Pinched Wires
- ECM - Failures
- A/T Oil Pump Case Bolt - Leaks
- A/T - Fluid Leaks from Oil Pump Body
- A/T Pump Body Assembly - Revised
- A/T - No Drive and Reverse
- A/T Oil Pump Seal Assembly - Leaking
- A/T - Replacement of the Pump Body Oil Seal Assembly
- A/T - Whine Noise In First, Second and Reverse
- A/T - Fluid Exhausting Out the Vent Pipe
- A/T - Oil Exhausting Out of the Breather
- A/T - New Pump Assembly Vane Rings
- A/T - THM 200 Pumps And Valve Bodies Interchangeability
- M/T Speedometer Driven Gear Sleeve - Leaks
- A/T - Oil Leak Diagnosis
- Input Clutch Housing Turbine Shaft - Revised
- New Rod End Clip - All THM 700-R4 Transmissions
- A/T - Firm or Harsh 1-2 Shift
- T..V. Exhaust Valve - Incorrect Mention of Component
- A/T - Shift Comments T.V. Cable Adjusting Won't Correct
- Fuel Injector - Preventing Electrical Damage During Test
- TBI Fuel Injectors - Remanufactured Parts Available
- Tools - Introduction Of The Fuel Injector Tester
- ECM - Revised Replacement Procedure
- Engine Controls - ECM May Contain Wrong PROM
- ECM - Packard 32 Way Connector Identification
- ECM - Packard 32-Way Connector Identification
- ECM/PCM - Damaged and/or Mis-Diagnosed
- ECM - Knock Retard Data Stream Changes
- Oxygen Sensor - Code 13 Set/MIL ON
- Oxygen Sensors - Silica Contamination
- Brake Pedal - High Operating Effort
- Brakes - Pulsation & On Car Rotor Turning
- Brakes - Parking Brake Service Adjustment Procedure
- Brakes - Rear Calipers Not Adjusting
- Brakes - Restricted Brake Fluid Passage Diagnosis
- Battery - Revised Parasitic Drain Ampmeter Connection
- Battery - Low or Dead Overnight or 2-3 Days
- Battery - Diagnosis and Charging
- Battery/Charging System - No Start Condition
- Warranty - New Vehicle/Replacement Battery
- Battery - Insulator Replacement & Caution
- Alternator Belt - Coming Off, Worn, Glazed or Broken
- Charging System - Abnormal Operation
- HEI Module - Testing Updated
- Engine - Surging After a Hot Soak
- Engine - Poor Driveability After Starting a Hot Soak
- CCC - Revised Varajet Carburetor Pre-Set Procedure
- Engine - Surge After a Hot Soak
- Accelerator Pumps, VITON - Two Types Available
- Carburetor - Adjustment Specification Revisions
- Fuel Line - O-Ring Composition
- Tools - Fuel Line Wrench Number Incorrectly Listed
- Threadlocking Compound - Packaging Change
- Engine - Hesitation on Light Acceleration
- Updated Canister Control Valve
- Canister Control Valve - Diagnosis Procedure
- Engine - Rough Idle/Rich Acceleration/Lean Idle
- EVAP - Canister Control Valve Mounting Procedure
- Engine - Effects of Top Engine Cleaner On CAT Converter
- Catalyst - Change Procedures For Dual Bed CAT
- Audio - Radio Frequency Interference (RFI) Diagnosis/ID
- Power Antenna Mast - No AM Reception With Replacement
- Cellular - Telephone Service Program
- Recall 85V169000: Shoulder Belt Defect
- Lap/Shoulder Belts - Dealer Installed Rear Kits
- Turn Signal Lever - Rattles
- IP Dimmer Control - Proper Setting
- Engine - Installation of 75 mm Oil Filter
- Tools - Use of Non OE Brake Lathe Cutting Tips
- Brakes - On-Car Rotor Turning Tool
- Brakes - Recommended Service Procedures
- Brakes - Rotor & Hub Flange Cleaning Tool Revision
- A/C - Refrigerant Loss Prevention
- Engine - Miss, Hesitation, or Roughness
- Engine - Power Loss, Hesitation, Roughness/Backfire
- Engine - Summary of Warm Ambient Driveability Problems
- HEI System - Description and Diagnosis Chart
- Starter Motor - Solenoid Clicks, Pinion Fails to Engage
- A/T - Overheating When Driven in Fourth Gear
- A/T - Early TCC Engagement, Stumble, Detonation
- Odometer/Speedometer - ACDelco Service Center Locations
- Brakes - Drag Condition, Adjustment of Brake Switch
- Pulse-Wiper - Spontaneous Operation
- Cylinder Head Gaskets - New Design
- Accessory Drive Belts - Break/Coming Off Pulleys
- Anti-Lock Brake - Aftermarket Products Usage Precaution
- Suspension - Squawking Noise From Rear
- Body - Diagnosis and Correction for Wind Noise
- Body - Aftermarket Equipment, Sheet Metal Corrosion
- Body - Sealer Tape For Collision Repairs
- Body - Complete or Partial Panel Repair
- Accessories (Aftermarket) - Installation Guidelines
- Engine - Provisions for Altitude Adjustments
- Emission Systems - State Testing Information
- Enhanced IM240 Program - Implementation Plan
- Emission - Enhanced Inspection Maintenance Programs
- I/M 240 Program - Equipment Purchase
- I/M Emissions Diagnostic Manual -Program
- Enhanced Emission I/M - Program Update
- Enhanced Emission Inspection Maintenance - Equipment
- Computer & Controls - Integrator/Block Learn Operation
- Engine Controls - Updated Rough/Unstable Idle Chart
- Revised CCC and EFI Diagnostic Charts
- Engine Controls - Static Electrical Damage Precaution
- Monitor II - Update Program
- Engine Controls - Diagnostic Chart Revisions
- EFI Diagnostic Charts - Updated
- Engine Controls - MAP Chart, DTC's 33, 34 ,63 ,64
- Oxygen Sensor Test - Revised Tech 1 Mass Storage CD
- Clock - Service Checklist
- Accelerator Pump, VITON - Additional Part Numbers
- Hatchback - High Closing Effort
- Engine Compartment - Water Entry
- Choke Light - Stays On
- Convertible Top - Cleaning and Care of Fabric
- Seat Belts - New Restraint System Service Information
- Child Restraint - Auxiliary Seat Belt
- Windshield - Two-Part Urethane Adhesive For Installation
- Wiper Blades - Chatter on Windshield
- Windshield Wiper Arm - Revision to Reduce Chatter
- T-Top Sealing Strips
- T-Top and Roof Area - Water Leaks
- T-Top - Water Leaks
- T-Top - New Weatherstrips
- Twin Lift-Off Panel - Water Leaks
- Rear Deck Luggage Carrier, A and J - Coming Loose
- Body/Paint - Repairing and Repainting Urethane Material
- Engine - Mobil Oil Corporation Engine Oil Press Release
- Engine Oil - Red Leak Detection Dye Added
- Water Pump Gasket - Leak
- Coolant - Information on Propylene Glycol Usage
- Warranty - Recycled Engine Coolant Policy
- Cooling System - Reconstituted Anti-Freeze
- Warranty - Engine Coolant Substitute Caution
- Wheels - Wire Wheel Cover Noise
- Wheels - Locking Wire Wheel Covers
- A/T - Burned 3-4 Clutch/High 2-3 Shifts
- A/T - Slipping/Premature Clutch Wear
- A/T - Slipping During 1-2 or 3-4, No 1-2 or 3-4 Upshift
- A/T Low and Reverse Piston - Installation or Removal
- A/T Oil Pressure Plugs - Revised
- A/T - 3T40/125C New Roller Clutch
- A/T - No Reverse or Slipping Reverse
- A/T - 4L60 Slipping or No 3rd/4th Gear
- A/T - Slipping or Loss of Drive Range
- A/T Reaction Sun Gear Shell Snap Ring - Revised
- A/T Selective Washer - Revised
- A/T - Forward Clutch Plate Modification
- A/T - Burned 3-4 Clutch Diagnosis
- A/T - New Design Selective Washer
- A/T - Summary Listing of Available Bulletins
- A/T - 2ND or 3RD Gear Starts
- A/T - Diagnosing Oil Leaks
- Tools - End Play Checking
- A/T - Fluid Leaks from Fill Tube
- M/T - Harsh Manual 2-1 Downshift/Delayed Downshifts
- A/T - Input Carrier to Output Shaft Snap Ring Assembly
- A/T Input Housing Assembly - Air Check
- A/T - No 2ND, 4TH or Reverse Gear Operation
- A/T - Possible Lack of Lubrication Check
- Tool Modification Required - Special Tool J-25013 (Support Fixt
- Shudder In Reverse Condition
- A/T - Unit Exchange Program
- A/T - Core Return Product Feedback Form
- A/T - Transmission End Play
- A/T - 200C/2004R Updated Servo Cover Retaining Ring
- A/T - THM 200 & 2004R New Transmission Oil Pan Gasket
- A/T - Converter Clutch Solenoid Fluid Source I.D.
- A/T - Torque Converter Identification
- A/T - 200, 325, 2004R, 3254L GM Servos
- A/T - Engine Vacuum Testing
- A/T - Diagnosing Converter Lock-Up Problems
- A/T - How To Use A Pressure Gauge
- A/T - 200/200C/200R4, 325/3254L, 700-R4 No 2nd Gear
- A/T - THM Late or No Upshifts
- A/T - No Converter Clutch Apply When Unit Is Hot
- A/T - 200/2004R, 325/3254L No Reverse/First Gear Only
- A/T - 200C Coastdown Clunk Condition
- A/T - Recurrent Sticking Valves/In Line Filters
- A/T - THM 200C Servicing Converter Clutch Apply Screen
- A/T - THM 200C In Reverse Range Engine Stops Running
- A/T - 200C/2004R, 700-R4 Lip Seal Packages Part Numbers
- A/T - Rapid Converter Pump Bushing Wear
- A/T - Converter Clutch Shudder
- A/T - 125, 200C/200 4R, 700 R4 Hidden Residue Build Up
- A/T - Sticking Throttle Valves
- A/T - 2004R/200C, 325 Soft 1-2 Shift
- A/T - Slipping Or No Third Gear After Overhaul
- A/T - 200/2004R, 325/3254L Harsh or Soft 2-3 Shift
- A/T - Governor Pressure Switches
- A/T - 200/200C No Passing Gear/Check Ball Mislocated
- A/T - Methods to Check for Restricted Exhaust
- A/T - THM 200/200C No Reverse
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - No Upshift/Governor Contamination
- A/T - THM Steel Clutch Piston Inspection
- A/T - Sprag Rotation
- A/T - THM 200C Ball Capsule Versus Cup Plug in TC
- A/T - Checking Pressure Switches For Leaks
- A/T - THM 200/200C No Passing Gear Above 35 MPH
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Gear Clash Shifting to 3rd or 4th Gear
- M/T - Neutral/Drive Gear Rattle
- Compact Disc Players - CD Changer Loading Procedures
- SIR - Operating Vehicle with Warning Light On
- A.I.R. Pump Pulley - Rattling Noise
- A/T - New Transaxle Fluid
- A/T - Procedure If ATF is Antifreeze Contaminated
- A/T - DEXRON III Fluid Introduction
- Engine - Stops Running Due to TCC Engagement
- Engine - Hard Start/Poor Warm Up Performance
- Oil Drain Plug Gasket - Revised Copper Gasket
- Coolant Temperature Sensor - Sensor Kit
- PROM/MEMCAL - Identification Marks
- Instrument Panel - Upper Surface Reflection
- Recall - Inoperative Canister Purge TVS
- Headlamp Door Motor Relays - Correct Mounting
- Suspension - Chassis Lubrication Importance
- Electrical - New Nickel Tape Shields Harnesses
- Fuel - How Fuel Economy Is Determined
- Engine - Poor Idle Caused by Vacuum Leaks
- Tires/Wheels - Wheel Weight Usage Precautions
- Speedometer Driven Gear Sleeve - Oil Leak
- T-Top - Parts/Usage Clarification
- Twin Lift-Off Panel Latch Assembly - Revised
- Power Antenna Rod and Cable - Service Package
- Recall - Front Seat Belt Shoulder Belt Retractor
- Carpet - Loose on Side Wall Trim Pads
- Body - Urethane Adhesives for Glass Applications
- Key Code - Information
- Refinish Paint - Interior/Exterior Identification Codes
- Paint - HVLP Application Information
- Paint - Alternative Stripping Procedures
- Warranty - Rail Dust Removal & Chemical Spotting Labor
- A/T - Revised Rear Case Bushing Procedure & Tool
- Trailer - Towing Information
- Oil Pressure Switch - Information
- A/T - 4L60 Binding or Inoperative In Reverse
- A/T - New Control Valve Assembly Identification
- A/T - Evaluating Peened Spacer Plates
- A/T - New Control Valve, Elimination of TCC Bore
- A/T - New Link Detent Lever to Manual Valve
- A/T - New Spacer Plate Identification Tab
- A/T - Reverse Gear Tie Up
- A/T - Proper Usage of Spacer Plate Gaskets, Overhaul Kit
- A/T - THM 200/200C Erratic Shift Patterns
- A/T - Erratic or No Upshift (Governor Drive Gear)
- A/T - Erratic or No Upshift
- A/T - Erratic or No Upshifts
- A/T - 4L60 Stuck In First Gear
- Drivetrain - Recommended Axle Lubricant
- Instrument Panel - Surface Cleaning
- A/T - New 2-4 Band, Apply/Anchor Brackets, Lube Window
- A/T - No Fourth Gear/Burned 2-4 Band Assembly
- A/T - Corrected 2-4 Servo Pin Torque Specification
- A/T - New 2-4 Servo Cover and Seal
- A/T - New Servo Apply Pin Information
- A/T - Accumulator Spring Usage Chart
- A/T Accumulator - Consistent Shift Points, Smoothness
- A/T - 1-2 Accumulator Piston/Outer Spring Replacement
- A/T - Modified Case 2nd, 3rd, 4th Clutch Pressure Taps
- Drivetrain - Revised Differential Case Assembly
- Contaminated R12 Refrigerant - Testing & Handling
- A/C - Retrofitting R-12 Vehicles to R-134A
- A/T Input Housing and Shaft Assembly - Service
- M/T - Gear Clash
- A/T - 4L60 New Output Shaft/Input - Output Seal
- A/T - New Procedure for R&R of Gear Washers & Sun Gear
- P/S - Reduced Assist When Cold
- P/S - Proper Fluid Usage, Not ATF
- Power Steering - Reduced Assist At Low Temperatures
- Fuel Tank Vent Valves - Undercoating
- Brakes, Front - Pulsation Diagnosis, Correction, Repair
- Recall 91V055000: Parking Brake Defect
- Fuel - Reformulated/Oxygenated Gasolines
- Fuel - Use of MTBE At 15% or Less In Gasolines
- Alignment - The Importance of Four Wheel Alignment
- A/T- Grinding Noise In All Ranges/No Drive Condition
- Front Seat Back - Noisy
- A/T Case Extension Oil Seal Assembly - Installing Tips
- Body - Metal Panel Adhesive Bonding Information
- Cooling System - Coolant Recycling Information
- M/T - Hydraulic Clutch Bleeding Procedure Improvement
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- Instruments - Reduced PRNDL Display Visibility
- Body - Polypropylene Energy Absorber Replacement
- Engine - Sealant Usage/Procedures
- Electrical - Aftermarket Fuse Warning
- Wheels - Chrome Wheel Brake Dust Accumulation/Pitting
- Brakes - Rotor Lateral Runout Correction Information
- Restraints - Usage of Used/Salvaged/Imitation Components
- A/T - 4L60, Revised Sprag/Forward Clutch Hub
- Fuel System - E85 Fuel Usage Precaution
- A/T - No Movement in Drive or 3rd Gear
- Engine/Fuel System - Oil/Fuel Additive Information
- Cooling System, A/C - Aluminum Heater Cores/Radiators
- Wheels/Tires - Upsized Wheel/Tire Characteristics
- Audio System - Refurbishing Radio Faceplates/Knobs
- Body - Hem Flange Rust Repair Information
- Body - Marks/Stains on Windshield When Wet
- Wheels/Tires - Chrome/Steel Valve Stem Cap Precautions
- Engine - Noise/Damage Oil Filter Application Importance
- Engine - Drive Belt Misalignment Diagnostics
- Body - Maintaining Exterior Weatherstrip Appearance
- 06-08-111-004B - BULLETIN CANCELLATION NOTIFICATION
- Body - Stain/Film On Windshield Glass Perimeter
- Wheels/Tires - Accessory Wheel And Tire Information
- Wheels/Tires - Replacement Wheel Weight Information
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Tires/Wheels - Tire Puncture Repair Procedures
- Lighting - Headlamp Warranty Replacement Guideline
- Interior - Proper Use of Floor Mats
- Wheels - Changing Procedures/Precautions
- Body - Squeeze Type Resistance Spot Welding/Equipment
- Electrical - Intermittent MIL/DTC P2138/Reduced Power
- Restraints - Extender Availability For Seat Belt
- Interior - Seat Cover Wrinkle/Crease/Burn Info
- A/T - Water Or Coolant Contamination Information
- Body - Drilling High Strength Steel Using CryoCobalt(R)
- Fuel System - TOP TIER Detergent Gasoline (Canada)
- Tires/Wheels - Information on Tire Radial Force Variation (RFV)
- Engine - GM Dexos 1(R) And 2(R) Oil Specifications
- Engine - GM dexos 1(R) and dexos 2(R) Oil Specifications/Info.
- Body - Pre-Painting/Cleaning Process For TPO Plastic Fascias
- Drivetrain - Information on Driveline Clunk Noise
- Wheels - Chromed Aluminum Wheel Staining/Pitting/Corrosion
- Body - Paint-less Dent Repair Process
- Wipers/Washers - Windshield Wiper Performance Information
- Electrical - Ground Repair Information
- Interior - Cleaning Instrument Panel, Interior Trim