Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Interior - Eliminating Unwanted Odors in Vehicles
- Body - Broken Rear Window Defogger Grid Detection
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Restraints - Seat Belt Latching Issues/Warning Lights
- A/C - Musty Odors Emitted From (HVAC) System
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Vehicle - Squeak And Rattle Diagnostic Guide
- Rear Drum Brakes - Sticking/Won't Release
- Check Oil and Check Gauges Lamp - Blink/Flicker
- A/C - Cut Off During Extended Idle Periods
- Steering - Squeak/Squawk Type Noise When Turning Wheel
- Brakes - Longer Life Front Brake Pad Lining
- A/C - Odor at Start up in Humid Climates
- Engine - Tick or Rattle After Start-Up
- Engine Rocker Cover - Oil Leak
- Engine - Oil Odors
- Exhaust System - Paint Peeling from Painted Muffler
- Wheels - Plastic Wheel Nut Covers Loose/Missing
- Spoiler - Water Intrusion
- Front Door Outer Belt Sealing Strip - Windnoise
- Engine/Transaxle - Excessive Engine Roll
- Fuel Injectors - Hard Starts/Poor Driveability/Misfire
- Engine - Tip-in Hesitation on Light Throttle Accel
- ABS - Indicator Remains ON/DTC's 21 and 22 Set
- ABS Indicator Lamp On, DTC 21,22,32 or 33 Set
- Brakes - ABS Light ON, DTC 46 & 86 (C1246 & C1286)
- Engine - Cold Start Stalls and/or Tip In Hesitation
- Accelerator Pedal - Hard to Depress/Cable Separation
- Two-Way Radios - Poor Performance
- Headlamp Lens - Distortion Caused by Aiming Equipment
- Parking Brake - Rear Wheel Brake Drag
- Interior - Squawk From Front Suspension Or Engine Area
- Air Bag (SIR) On-Off Switch Kits, New Parts and Service
- Washer Pump - Will Not Prime or Pump Washer Fluid
- Rear Compartment Lid Hinge Covers - Loose/Rattle
- Door Handles - On White Painted Vehicles Turning Yellow
- Right Side Quarter Window - Wind Noise/Water Leak
- Side Moldings - Discolored/Stained Inserts
- Engine - Increased Oil Consumption
- A/T - Intermittent, NEUTRAL Condition at Highway Speeds
- M/T - Click Noise or Gear Disengagement in Reverse
- Compact Disc Players - CD Changer Loading Procedures
- SIR - Operating Vehicle with Warning Light On
- Strut Mount - Popping Noise Heard With Engine Movement
- Accessory Receptacle/Cigar Lighter - Inoperative
- Ignition - Engine Miss, Updated Spark Plug Wires
- Fuel Filler Door - Will Not Open
- I/P Cluster Hood - Collects Condensation
- Instrument Panel - Upper Surface Reflection
- Charging - Low Voltage Reading Or Dim Lights At Idle
- Steering - Squeak/Squawk Noise at Bottom of Column
- Starting - Revised Procedures for Inop Ignition Cylinder
- Power Door Locks - Inoperative/Manual Function OK
- Brakes - Various Noises When Applying Brakes
- Brakes, Front - Pulsation Diagnosis, Correction, Repair
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- Engine - Oil Leaks from Crankshaft Rear Main Seal
- Engine - Oil Leaks From Front Crankshaft Seal
- A/T - No Movement in Drive or 3rd Gear
- A/T - 4L60/65E, No Reverse/2nd or 4th Gear
- Body - Marks/Stains on Windshield When Wet
- Body - Bumps or Rust Colored Spots in Paint
- Body - Stain/Film On Windshield Glass Perimeter
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Labor/Parts Updates
- Recommended Repairs
- Superceded Bulletins
- All Technical Service Bulletins
- Interior - Eliminating Unwanted Odors in Vehicles
- Locks - Key Code Security Rules, Key Code Look Up
- Vehicle - Engine And Sub Systems Flushing Info. (CANADA)
- Vehicle - Engine And Sub-Systems Flushing Recommendations
- Wheels/Tires - Use Of Nitrogen Gas In Tires
- Tires - Information On Proper Tire Pressure
- Engine - THIS BULLETIN HAS BEEN CANCELED
- Fuel System - TOP TIER Detergent Gasoline Information (Canada)
- Fuel System - TOP TIER Detergent Gasoline
- Tires/Wheels - OE Tire Shake/Vibration Information
- Suspension - Shock Absorber/Strut Fluid Leak Information
- M/T - Operating Characteristics Information
- Brakes - Resurfacing Park Brake Portion of Rear Brake Rotor
- Body - Hem Flange Sealer For Corrosion Protection
- Engine - Intake Manifold Inspection/Replacement
- Body - Metal Body Panel Corrosion Protection
- Fuel System - GM Fuel System Treatment PLUS(R) Info.
- Body - Broken Rear Window Defogger Grid Detection
- Fuel System - Fuel Injector Maintenance Cleaning
- Audio - Inadvertent Steering Wheel Button Activation
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- A/T - Fluid Oil Cooler Flow Test
- Restraints - Child Seat Top Tether Attachment Kits
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Restraints - Passenger Presence System Information
- Lighting - Lamp Polycarbonate Lens Damage Prevention
- Restraints - Seat Belt Latching Issues/Warning Lights
- Body - Side Window Chipping Information
- Restraints - Driver/Passenger Seat Head Rest Information
- Engine - Use of 'Surface Conditioning Disks'
- Body - Application of Anti-Corrosion Materials
- A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
- A/C - Musty Odors Emitted From (HVAC) System
- A/T - Slight Vehicle Movement In Park At Start Up
- A/T - DEXRON(R)-VI Fluid Information
- Wheels/Tires - Refinishing Aluminum Wheels
- Lighting - Exterior Lamp Condensation and Replacement
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Steering/Suspension - Wheel Alignment Specifications
- Warranty - Claims Submission
- Warranty - Goodwrench Service Lifetime Service Guarantee
- Warranty - GM Dealer Parts Procurement
- Warranty - Labor Time Guide Updates, 09/99
- Warranty - Notice of Delayed Start Process
- Warranty - Parts Warranty Special Claims B and C
- Warranty - Labor Time Guide Update
- Warranty - Request for Wholesale Authorization
- Warranty Inquiry System
- Customer Concern Not Duplicated /Verified - Labor
- Warranty - Courtesy Transportation Guidelines
- VIN Plate - Replacement Policy and Procedure
- Warranty - GM Dealer Empowerment Program
- Labor - Revised Operation Z1241/Personal Property Damage
- Warranty - Repair/Replace Policies & Procedures
- Parts Expediting - Reimbursement Policy
- Warranty - Enhanced Sublet Repair Policy
- Warranty - Labor Time Guide Addition
- Warranty - Required Claim Submission Procedures
- Warranty - Repair and Claims Procedures
- Warranty - Claim Processing
- Warranty - Claims Processing
- Warranty - Corporate Parts Return Program Instructions
- Paint - Information and SPID Label
- Vehicle - Squeak And Rattle Diagnostic Guide
- Warranty Information Network System - Stage 2
- Vehicle - Use of a Diagnostic Worksheet
- Labor Time Guide - Format Change
- GM Campaign Identification Label
- Vehicle - AC Delco Locator Service, Electronics Exchange
- Campaign - Product Bulletin Numbering System
- I/M 240 Repairs - Obtaining Technical Assistance
- Brake Fluid - Level And Filling Recommendations
- Rear Drum Brakes - Sticking/Won't Release
- Instrument Cluster - Identification
- Check Oil and Check Gauges Lamp - Blink/Flicker
- Electrical - Instrument Panel And General Wiring Repair
- A/C - Cut Off During Extended Idle Periods
- Tools - A/C Leak Detector Maintenance Kit Availability
- A/C - Systems With R12 Or R134a Service Issue
- A/C - Tool And Equipment Maintenance
- A/C - PureGuard 2 Operating Alert
- A/C - System Sealers/Leak Detection Guidelines
- A/C - R-134a System Flushing Procedures
- Tools - Power Steering Bleeder Adapter
- Steering - Squeak/Squawk Type Noise When Turning Wheel
- ACDelco(R) Remanufactured Transmissions - Program Update
- Engine - Surface Conditioning Discs Precautions
- Engine - AC Delco Remanufactured Engines
- Brakes - Longer Life Front Brake Pad Lining
- A/C Compressor Seal Washer - Reference Chart
- A/C - Unnecessary Compressor Replacement
- A/C - Odor at Start up in Humid Climates
- Suspension - Shock Absorber/Strut Replacement Guidlines
- Tools - Adjuster Locknut Wrench
- Engine - Piston Pin Removal/Installation Revision
- Timing Chain and Sprocket - Revised Installation
- Engine - Pushrod Identification Revised
- Engine - Tick or Rattle After Start-Up
- Engine Rocker Cover - Oil Leak
- Cooling - Radiator Repair/Replacement Guidelines
- Engine - Oil Odors
- Piston Pin Clearance Specification - Revision
- Exhaust System - Paint Peeling from Painted Muffler
- Lower Intake Manifold - Revised Tightening Procedure
- Brake Pad/Caliper/Knuckle - Inspect & Maintenance
- Aluminum Wheels - Refinishing
- Warranty - Guidelines for Using E0420 Wheel Replace
- Warranty - OE Chrome Plated Aluminum Wheel ID
- Wheels - Plastic Wheel Nut Covers Loose/Missing
- Spoiler - Water Intrusion
- Automatic Door Lock - Does Not Work, New Chart
- Leather Seat Covers - Cleaning Procedure
- Front Door Outer Belt Sealing Strip - Windnoise
- Engine/Transaxle - Excessive Engine Roll
- A/T - Oil Cooler Flushing Frequently Asked Questions
- Tools - Introduction Of The Fuel Injector Tester
- Fuel Injectors - Hard Starts/Poor Driveability/Misfire
- Powertrain Control Module Pin-Outs - Revised
- Manual Update - Revised PCM Connector (A) End View
- Engine - Tip-in Hesitation on Light Throttle Accel
- PROM - Reprogram Using Off Board Program Adapter
- Oxygen Sensors - Silica Contamination
- ABS - Indicator Remains ON/DTC's 21 and 22 Set
- ABS Indicator Lamp On, DTC 21,22,32 or 33 Set
- Brakes - ABS Light ON, DTC 46 & 86 (C1246 & C1286)
- Brakes - Wheel Cylinder Inspection Guidelines
- Electronic Brake Control Module Relay - Revised Location
- Battery - Diagnosis and Charging
- Updated Battery Replacement Catalog Numbers
- Warranty - New Vehicle/Replacement Battery
- Battery - Insulator Replacement & Caution
- Battery - Testing Equipment Explained
- Battery - Parasitic Drain
- Tools - Released for CS Generator Diagnosis
- Electrical - Fusible Links A, B and C Color Changes
- Recall 00V287000: Ignition Switch Starter Circuit Defect
- SPS/EEPROM - Programming Chart
- SPS/FLASH EPROM - Programming
- Engine - Cold Start Stalls and/or Tip In Hesitation
- PROM - Powertrain Control Module Reprogramming
- Accelerator Pedal - Hard to Depress/Cable Separation
- Multi-Function Alarm Module - Diagnostics Revision
- Cruise Control Module - Location Revised
- Two-Way Radios - Poor Performance
- Audio - Procedure To Handle Customer Radio Concerns
- Radio Telephone/Mobile Radio - Install/Troubleshooting
- Air Bag - Module Shipping/Return Procedure
- IP Dimmer Control - Proper Setting
- Brakes - Rotor Warranty Service Procedure
- Brakes - Rotor & Hub Flange Cleaning Tool Revision
- Engine - Cranks But Will Not Run/Chart Revision
- Odometer/Speedometer - ACDelco Service Center Locations
- Headlamp Lens - Distortion Caused by Aiming Equipment
- Headlamp Switch Wiring - Schematic Revision
- Turn Signal Flasher - Location Revised
- Parking Brake - Rear Wheel Brake Drag
- ABS Motor Pack Removal Procedure - Revised
- Interior - Squawk From Front Suspension Or Engine Area
- Center Pillar Upper - Addition of Water Deflector
- Body - Sealer Tape For Collision Repairs
- SIR DTC 24 Diagnosis
- SIR - Revised Disable/Enable Procedure
- SIR System - Revised DTC 24 Diagnostic Chart - SIR
- Air Bag (SIR) On-Off Switch Kits, New Parts and Service
- Airbags - Frontal (SIR) ON-Off Switch Kits, Parts/Procs
- Restraints - Air Bag System Diagnostics
- Security & Remote Keyless Entry System - Revision
- Enhanced IM240 Program - Implementation Plan
- I/M 240 Program - Equipment Purchase
- I/M Emissions Diagnostic Manual -Program
- Enhanced Emission I/M - Program Update
- Enhanced Emission Inspection Maintenance - Equipment
- Warranty - Guidelines for I/M 240 Labor
- Emissions Inspection/Maintenance - Labor Operations
- EVAP System - Service of Connectors
- Oxygen Sensor Test - Revised Tech 1 Mass Storage CD
- Tech 1 & VIM - ECM Programming
- PCM - Returned Product Feedback Program
- Trap Resistant Trunk Kit - Function/Installation
- Washer Pump - Will Not Prime or Pump Washer Fluid
- Windshield Wiper/Washer - Diagnostics Revisision
- Rear Compartment Lid Hinge Covers - Loose/Rattle
- Door Handles - On White Painted Vehicles Turning Yellow
- Hood - Removal Without Breaking MIG Welds
- Child Restraint - Auxiliary Seat Belt
- Windshield - Reveal Molding Etching Precaution.
- Windshield - Two-Part Urethane Adhesive For Installation
- Warranty - Guidelines for Claiming Windshield Replace
- New Windshield/Glass Urethane Adhesive Caulking Kit
- Right Side Quarter Window - Wind Noise/Water Leak
- Polypropylene Foam Energy Absorbers - Repair
- Side Moldings - Discolored/Stained Inserts
- Extended Life Engine Coolant - DEX-COOL(TM)
- Engine Coolant - Information on Back Service
- Engine - Roller Rocker Arms vs, Ball & Pivot Rocker Arms
- Engine - Increased Oil Consumption
- Automatic Transaxle - Product Update
- A/T - 4T60E Cold Start Rattle Noise
- A/T - Intermittent, NEUTRAL Condition at Highway Speeds
- A/T - New Solenoid Testing Kit
- A/T - Service Procedure Changes
- A/T - Core Return Product Feedback Form
- A/T - Diagnosing Fluid Leaks
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - 4T60E Oil Scoop Eliminated
- A/T - 4T60E New Design Pump Body And Rotor
- A/T - 4T60E Torrington Bearing Replaced
- A/T - 4T60E Wiring Harness Updates
- A/T - 4T60E 3rd Sprag Clutch Replaces 3rd Roller Clutch
- A/T - 4T60E New Design Input Clutches
- A/T - 4T60E Redesigned TCC Solenoid
- A/T - Harsh Forward Engagement
- A/T - 4T60E 2nd Gear Starts, Shifts 1-3
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Click Noise or Gear Disengagement in Reverse
- Compact Disc Players - CD Changer Loading Procedures
- SIR - Operating Vehicle with Warning Light On
- Crankcase Ventilation System - Revised Maintenance
- Strut Mount - Popping Noise Heard With Engine Movement
- Engine - Serpentine Drive Belt Wear Information
- A/T - DEXRON III Fluid Introduction
- Accessory Receptacle/Cigar Lighter - Inoperative
- Ignition - Engine Miss, Updated Spark Plug Wires
- PROM/MEMCAL - Identification Marks
- Fuel Filler Door - Will Not Open
- I/P Cluster Hood - Collects Condensation
- Instrument Panel - Upper Surface Reflection
- Suspension - Chassis Lubrication Importance
- Engine - New Prelube Tool
- Charging - Low Voltage Reading Or Dim Lights At Idle
- Cruise Control - (W/Electro Stepper Mtr.) Diagnostics
- Cruise Control - Revised Diagnostic Chart
- Tires/Wheels - Wheel Weight Usage Precautions
- Seat Belt System - Collision Replacement Guidelines
- Body - Urethane Adhesives for Glass Applications
- Key Code - Information
- Key/Key Number/Security Chip - Replacement
- Entertainment Systems - Correct Labor Codes
- Paint - Polishing And Swirl Mark Removal
- Paint - Basecoat/Clearcoat Paint Systems Specifications
- Warranty - Rail Dust Removal & Chemical Spotting Labor
- Steering - Squeak/Squawk Noise at Bottom of Column
- Ignition Key and Lock Cylinder - Revised
- Starting - Revised Procedures for Inop Ignition Cylinder
- Tools - Keyless Entry Transmitter Tester
- A/C - R134a Leak Detection With Tracer Dye
- A/C - R12 or R134a Service Recommendations
- A/C - Refrigerant Recovery/Recharge Equipment
- Daytime Running Lamp - Retrofit Kits
- Power Door Locks - Inoperative/Manual Function OK
- Brakes - Various Noises When Applying Brakes
- Brakes, Front - Pulsation Diagnosis, Correction, Repair
- Fuel - Reformulated/Oxygenated Gasolines
- Fuel - Top Tier Detergent Gasoline Information
- Wheel Alignment - Specifications Revision
- A/C - New PAG Oil
- Vehicle - Recreational (Dinghy) Towing Information
- Body - Metal Panel Adhesive Bonding Information
- Cooling System - Coolant Recycling Information
- A/C - Contaminated R134A Refrigerant
- M/T - Hydraulic Clutch Bleeding Procedure Improvement
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- Instruments - Reduced PRNDL Display Visibility
- Body - Polypropylene Energy Absorber Replacement
- Engine - Sealant Usage/Procedures
- Engine - Oil Leaks from Crankshaft Rear Main Seal
- Electrical - Aftermarket Fuse Warning
- Engine - Oil Leaks From Front Crankshaft Seal
- Wheels - Chrome Wheel Brake Dust Accumulation/Pitting
- Electrical - Battery Charging Tips/Recommendations
- Brakes - Rotor Lateral Runout Correction Information
- Restraints - Usage of Used/Salvaged/Imitation Components
- Fuel System - E85 Fuel Usage Precaution
- A/C - Refrigerant Recovery/Recycling/Equipment
- A/T - Torque Converter Replacement Information
- A/T - No Movement in Drive or 3rd Gear
- A/T - Grinding/Growling Noise in Park on Incline
- A/T - 4L60/65E, No Reverse/2nd or 4th Gear
- Engine/Fuel System - Oil/Fuel Additive Information
- Charging System - Low Voltage Display/Battery Discharged
- Cooling System, A/C - Aluminum Heater Cores/Radiators
- Wheels/Tires - Upsized Wheel/Tire Characteristics
- Audio System - Refurbishing Radio Faceplates/Knobs
- A/T Control - DTC P0756 Diagnostic Tips
- Body - Hem Flange Rust Repair Information
- Body - Marks/Stains on Windshield When Wet
- Wheels/Tires - Chrome/Steel Valve Stem Cap Precautions
- Body - Bumps or Rust Colored Spots in Paint
- Engine - Noise/Damage Oil Filter Application Importance
- Engine - Drive Belt Misalignment Diagnostics
- Body - Maintaining Exterior Weatherstrip Appearance
- 06-08-111-004B - BULLETIN CANCELLATION NOTIFICATION
- Body - Stain/Film On Windshield Glass Perimeter
- Wheels/Tires - Accessory Wheel And Tire Information
- Wheels/Tires - Replacement Wheel Weight Information
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Tires/Wheels - Tire Puncture Repair Procedures
- Lighting - Headlamp Warranty Replacement Guideline
- Mirrors - Heated Mirrors, Defrosting Time
- Interior - Proper Use of Floor Mats
- Wheels - Changing Procedures/Precautions
- Body - Squeeze Type Resistance Spot Welding/Equipment
- Restraints - Extender Availability For Seat Belt
- Interior - Seat Cover Wrinkle/Crease/Burn Info
- A/T - Water Or Coolant Contamination Information
- Body - Drilling High Strength Steel Using CryoCobalt(R)
- Body - Vehicle Glass Distortion Information
- Fuel System - TOP TIER Detergent Gasoline (Canada)
- Tires/Wheels - Information on Tire Radial Force Variation (RFV)
- Engine - GM Dexos 1(R) And 2(R) Oil Specifications
- Engine - GM dexos 1(R) and dexos 2(R) Oil Specifications/Info.
- Body - Pre-Painting/Cleaning Process For TPO Plastic Fascias
- Drivetrain - Information on Driveline Clunk Noise
- Wheels - Chromed Aluminum Wheel Staining/Pitting/Corrosion
- Body - Paint-less Dent Repair Process
- Wipers/Washers - Windshield Wiper Performance Information
- Electrical - Ground Repair Information
- Interior - Cleaning Instrument Panel, Interior Trim