Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Interior - Water Leakage
- Body & Frame - Noise Complaints From the Rear
- Engine - Excessive Oil Consumption
- Fuel Pump - Poor Driveability, Noisy
- Fuel Pump - Poor Driveability, Noisy Operation
- Wheel Bearing, Front - Clunking Noise
- Timing Chain - Rattles/Chatters
- Engine - Lifters Noisy
- Engine - Lifter Noise
- Exhaust - Leakage Between Front Pipe and Manifold
- Exhaust - Sulfur Smell
- Heater - Fluctuating Output
- Rear Spoiler - Water Leakage
- Seat Backrest - Angle Readjustment Complaint
- Drive Axles - Vibration at Idle
- A/T - Oil Pan Leakage
- Fuel System - Poor Driveability Upon Start Up
- Positive Battery Cable - Relocation
- Fuel System - Engine Driveability Problems
- Radio/Stereo - Rattling Noise
- Radio - Power or Listening Gap in Volume
- Radio, Clarion - Erratic Volume Control
- Ignition - Cold Weather Starting Problems
- Rear Hatch - Correcting A Latching Complaint
- Convertible Top - Fabric Wear
- Engine - Starting Problems In Sub Zero Temperatures
- Engine - Hard Cold Weather Starting
- Engine - Cold Weather Starting Problems
- Convertible Top - Door Window Glass Slippage
- Convertible Top - Contacts Window Frame During Closing
- Audio - Noise Distortion at High Equalizer Settings
- Engine - Poor Starting/Driveability Concerns
- Handbrake Button - Sticking
- Heating - Flow of Heat From Heater Core Fluctuates
- Seat Cover - Wear On Front Seat Backrest
- Body - Stain/Film On Inside Perimeter Of Windshield
- Seals, Gaskets
- Tools, Equipment
- Superceded Bulletins
- 05-06-04-022C - 12/01/06
- 05-06-04-022A - 01/01/06
- 05-06-04-022 - 12/30/05
- 12871017 - 12/01/87
- 10910138 - 911001
- 08900017 - 08/01/90
- 0787986 - 07/01/87
- 06900009 - 06/01/90
- 03891123 - 03/01/89
- 02910086 02/01/91
- Paint - Color Codes/Cross References
- Extended Length Seat Belt - Availability
- Passive Seat Belt System - Tester
- A/C - R134a Compressors for Converted Systems
- Recall - Wiring Harness Chafing
- Fuel System - Top Tier Gasoline Usage (Canada)
- Fuel System - TOP-TIER Gasoline Usage (Canada)
- Spark Plug - Reference
- All Technical Service Bulletins
- TSB 068911490 Dated 06/01/89 is No Longer Available.
- TSB 0178291 Dated 01/01/78 is No Longer Available
- Expander Rivet Extraction Tool
- Tool - Revised Tip for Connector Pin & Socket Removal
- Warranty Policy - Use of Genuine Parts Only
- Maintenance - Lubricants, Fluids, and Other Supplies
- Tool - New Female Connector Pin Removal
- Tow Line - Availability
- Warranty Manual - Updated Information
- Interior - Water Leakage
- Recall 88V173000: Wiring Harness Chafing
- Body & Frame - Noise Complaints From the Rear
- Technical Highlights/Service Reminders
- Corporate Emblem - Program For Replacement
- Tool Kit - New Torx Bit
- A/C - R12 to R134a Refrigerant Retrofit
- A/C System - R12 to R134a Conversion/Retrofit
- Tool - PS Pump Puller Upgrade Adapter Button
- Engine - Excessive Oil Consumption
- Tool - Upgrade Adapter Button For the P/S Pump Puller
- Tool - P/S Pump Puller (Upgrade) Adapter Button
- Power Steering Pump Puller - Adapter Upgrade
- Fuel Pump - Poor Driveability, Noisy
- Fuel Pump - Poor Driveability, Noisy Operation
- Fuel Pump - Installation Procedure For New Fuel Tank
- Fuel Pump/Gear Selector - Special Tools
- Brake Pad - Revised Recommendations
- Brake Pads - Approved Designs/Applications
- Brakes - Brake Pad Information
- Spark Plug - Application Reference
- Fuel System - Driveability Improvement
- A/C System - R134 Conversion Compressors
- Heater Fan Kit/Resistor - Return of Parts
- Wheel Bearing, Front - Clunking Noise
- Crankshaft - Flywheel Alignment Pin Revised
- Timing Chain - Rattles/Chatters
- Cylinder Head - 1,000 Mile Retorque Elimination
- Cylinder Head - Exchange Components
- Cylinder Head - Resurfacing Information
- Cylinder Head - Production Change
- Cylinder Head - Resurfacing
- Engine - Lifters Noisy
- Engine - Lifter Noise
- Engine Block - Pitting Correction
- Radiators - Modifying Fan Shrouds
- Exhaust - Leakage Between Front Pipe and Manifold
- Exhaust - Sulfur Smell
- Heater - Fluctuating Output
- Alloy Wheels - Part Numbers/Applications
- Rims/Tires - Vibration Diagnosis
- Radial Tire - Repair Information
- Radial Tire - Repair
- Rear Spoiler - Water Leakage
- Body - Airflow Components
- Seat Backrest - Angle Readjustment Complaint
- Front Seats - Odering Replacement Parts
- Headliners - Microfiche Correction
- Drive Axles - Vibration at Idle
- Outboard Drive Shaft CV Joint - Normal Noises
- A/T - Oil Pan Leakage
- Clutch - Revised Slave Cylinder & Tools Available
- Fuel Injectors - Testing With VITON Rubber Valve Seats
- Fuel System - Poor Driveability Upon Start Up
- Oxygen Sensor - Revised Maintenance Schedule
- Lambda Sensor - Using ISAT to Check Pulse Ratio
- Automatic Idle Control Valve - Troubleshooting
- CV Joint - New Boot Clamps
- Tool - For Installing CV Joint Boot Clamps
- Brake Calipers - Exchange Program
- Front Brake Calipers - Exchange Components
- Alternator - Exchange Component Part Numbers
- Positive Battery Cable - Relocation
- Ignition Switch - Contacts Binding
- Ignition System - Knock Detector Cable Replacement
- Fuel System - Engine Driveability Problems
- Throttle Valve - Basic Setting
- Throttle Valve - Basic Setting Information
- Turbocharger Air Bypass Valve - Problem Diagnosis
- Check Engine Light - Resetting
- Radio - Interference When Tuned to Weak Stations
- Guard Alarm - Replacement Alarm Module
- Cruise Control Switch - Replacement Revisions
- Radio/Stereo - Rattling Noise
- Radio - Power or Listening Gap in Volume
- Radio Bracket - Installation/Removal
- Radio, Clarion - Erratic Volume Control
- Seat Belt Button - Replacing
- Extended Length Safety Belt - Availability
- Engine Oil Filters/Drain Plug Gaskets - Part Numbers
- Brake Rotor - Measuring Fixture
- Brake Rotors - Resurfacing/Replacement Guidelines
- EZK Ignition System - Tester Modification
- Ignition - Cold Weather Starting Problems
- Starter - Exchange Component Part numbers
- Cylinder Head Gasket - Revised
- Hand Brake Cable - Availability
- Recall 88V149000: Front Control Arm Bolts Defective
- SRS - Troubleshooting Advice
- Airbag - Component Replacement Update
- Vehicle - Technical Tip Bulletin
- Saab Guard Alarm - Adjustment
- Alarm System - Power Supply Wiring Revision
- Technical Tips - PSI Bulletins
- Antitheft - ROM Chip Precautions & Procedure
- Evaporative System - Leak/Pressure Testing
- ISAT Scan Tool Diagnostics Set - Changes
- Tools - ISAT TECH 2
- ISAT Scan Tool - Repair Procedure
- Rear Hatch - Correcting A Latching Complaint
- Convertible Top - Fabric Wear
- Windshield - Installation On Convertible Vehicles
- Door Window Glass - Proper Installation
- Wiper Blades - Care/Maintennance
- A/T - Oil Cooling System Flushing
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Loctite 510 Availability
- Engine Mount Bracket - Revised Design
- Recall - Lower Control Arm Attachment Bolts
- Fog Lights - Applications/Part Numbers
- Engine - Starting Problems In Sub Zero Temperatures
- Tool - New Test Cables for Breakout Box
- Tools - LH Injection System Tester
- Recall 88V173000: Wiring Harness Chaffing
- Recall Announcement - Wire Chafing Prevention
- Campaign - Video for Recall 273 - Wiring Chafing
- Wiring - Terminal Repair Kit Contents
- Engine - Hard Cold Weather Starting
- Engine - Cold Weather Starting Problems
- Cruise Control - Testing & Tools
- Tool - Checking Toe In
- Convertible Top - Door Window Glass Slippage
- Convertible Top - New Adjustment Specification
- Convertible Top - Contacts Window Frame During Closing
- Convertible Top Soft Boot Cover - Availability
- Tools - Seat Belt System Tester
- Passive Belt System - Power Circuit Modification
- Rubber Floor Mats - Availability
- Interior Trim - New Upholstery Material
- Audio - Noise Distortion at High Equalizer Settings
- Radio Bracket - Removal Tools
- Paint - Codes/Cross References
- Rear Mud Flap Kit - Installation
- Engine - Poor Starting/Driveability Concerns
- Trailer Hitch - Installation
- Handbrake Button - Sticking
- Heating - Flow of Heat From Heater Core Fluctuates
- A/C - Refrigerant Recycling Equipment
- Seat Temperature Control Switch - Bulb Repair Kit
- Convertible Top - Checking Hydraulic Fluid Level
- Scheduled Maintenance - Labor Times
- Specialized Fluids, Lubricants and Supplies
- CD Changer - Manually Releasing a CD
- Seat Cover - Wear On Front Seat Backrest
- Fuel System - TOP TIER Detergent Gasoline
- Body - Stain/Film On Inside Perimeter Of Windshield
- Wheels - Chrome Wheel Staining/Pitting/Corrosion