Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Interior - Water Leakage
- Engine - Long Cranking Time On Restart
- Wheel Bearing, Front - Clunking Noise
- Timing Chain - Rattles/Chatters
- Exhaust - Sulfur Smell
- Heater - Fluctuating Output
- Rear Spoiler - Water Leakage
- Front Seat Back Guide Pins - Proper Alignment
- Hood Seal - Squeaking Noise
- Drive Axles - Vibration at Idle
- Fuel System - Poor Driveability Upon Start Up
- EGR System - MIL ON Intermittently
- Battery - Dies For No Apparent Reason
- EGR System - MIL is ON Intermittently
- Exhaust - Sulfur/Rotten Egg Smell
- Cruise Control - Inoperative
- Cooling Fan - Continuous Running/Dead Battery
- Convertible Top - Fabric Wear
- Upper Center Windshield - Whistling Noise
- A/T - Idle Increase & Backup Light Malfunction
- Engine - Hard Cold Weather Starting
- Convertible Top - Door Window Glass Slippage
- Convertible Top - Contacts Window Frame During Closing
- Engine - Poor Starting/Driveability Concerns
- Body - Stain/Film On Inside Perimeter Of Windshield
- Recommended Repairs
- Seals, Gaskets
- Tools, Equipment
- Superceded Bulletins
- 05-06-04-022C - 12/01/06
- 05-06-04-022A - 01/01/06
- 05-06-04-022 - 12/30/05
- 890-18073 - 09/01/99
- 11891186 - 11/01/89
- 11891185 - 03/01/90
- 10910138 - 911001
- 09900025 - 09/01/90
- 08900017 - 08/01/90
- 0787986 - 07/01/87
- 06900009 - 06/01/90
- 03901227 - 04/01/90
- 03901221223 - 03/01/90
- 03891123 - 03/01/89
- 02910086 02/01/91
- Paint - Color Codes/Cross References
- Extended Length Seat Belt - Availability
- A/C - R134a Compressors for Converted Systems
- ABS and TC/ABS - Diode Diagnosis & Repair
- Fuel System - Top Tier Gasoline Usage (Canada)
- Fuel System - TOP-TIER Gasoline Usage (Canada)
- Radiator Fan Time-Delay Relay - May Not Shut Off
- Engine Oil Drain Plug - Revised
- Cylinder Head Plug - Microfiche Discrepancy
- Spark Plug - Reference
- All Technical Service Bulletins
- TSB 068911490 Dated 06/01/89 is No Longer Available.
- TSB 0178291 Dated 01/01/78 is No Longer Available
- Expander Rivet Extraction Tool
- Tool - Revised Tip for Connector Pin & Socket Removal
- Tool - Electrical Connector Pin Removal
- Tools - Required Special Tools
- Tools - New Required Special Tools
- Warranty Policy - Use of Genuine Parts Only
- Maintenance - Lubricants, Fluids, and Other Supplies
- Superceding Part number Listing
- Tow Line - Availability
- Warranty Manual - Updated Information
- Interior - Water Leakage
- Warranty - Manual Updates
- Listing of Parts Supersessions
- A/C - R12 to R134a Refrigerant Retrofit
- A/C System - R12 to R134a Conversion/Retrofit
- Engine to Gearbox - Improved Sealing
- Engine - Long Cranking Time On Restart
- Fuel Pump/Gear Selector - Special Tools
- Brake Pad - Revised Recommendations
- Brake Pads - Approved Designs/Applications
- Brakes - Brake Pad Information
- Spark Plug - Application Reference
- A/C System - R134 Conversion Compressors
- Heater Fan Kit/Resistor - Return of Parts
- Wheel Bearing, Front - Clunking Noise
- Crankshaft Pulley Bolt - Socket
- Timing Chain - Rattles/Chatters
- Cylinder Head Plug - Incorrect Illustration in Fiche
- Cylinder Head - Resurfacing
- Engine Block - Pitting Correction
- Engine Block - Deck Surface Pitting
- Cooling Fans - Microfiche Discrepancy
- Exhaust - Sulfur Smell
- Heater - Fluctuating Output
- Alloy Wheels - Part Numbers/Applications
- Snow Tire Program and Winter Accessories
- Rims/Tires - Vibration Diagnosis
- Radial Tire - Repair Information
- Snow Tire - Program
- Radial Tire - Repair
- Rear Spoiler - Water Leakage
- Body - Airflow Components
- Front Seat Back Guide Pins - Proper Alignment
- Front Seats - Odering Replacement Parts
- Hood Seal - Squeaking Noise
- Headliners - Microfiche Correction
- Special Tools - Transmission and Headliner Repair
- Drive Axles - Vibration at Idle
- Outboard Drive Shaft CV Joint - Normal Noises
- Revised Differential - Adjustment Procedure
- A/T Components - Microfiche Discrepancy
- Clutch - Revised Slave Cylinder & Tools Available
- Fuel System - Poor Driveability Upon Start Up
- EGR System - MIL ON Intermittently
- Lambda Sensor - Using ISAT to Check Pulse Ratio
- CV Joint - New Boot Clamps
- Tool - For Installing CV Joint Boot Clamps
- ABS/TCS/ASR/ETS - Exchange Components
- Front Brake Calipers - Exchange Components
- Battery - Dies For No Apparent Reason
- Special Tool - Battery Tester 311
- Alternator - Exchange Component Part Numbers
- Ignition Switch - Contacts Binding
- Turbocharger Air Bypass Valve - Problem Diagnosis
- Recall - MIL Indicates No EGR Flow
- EGR System - MIL is ON Intermittently
- Exhaust - Sulfur/Rotten Egg Smell
- Radio - Interference When Tuned to Weak Stations
- Guard Alarm - Replacement Alarm Module
- Cruise Control - Inoperative
- Seat Belt Button - Replacing
- Extended Length Safety Belt - Availability
- Front Airbag Front Sensor - Captive Nut Replacement
- Airbag Front Sensor - New Design
- Engine Oil Filters/Drain Plug Gaskets - Part Numbers
- Brake Rotor - Measuring Fixture
- Brake Rotors - Resurfacing/Replacement Guidelines
- EZK Ignition System - Tester Modification
- Starter - Exchange Component Part numbers
- Radiator Fan Relay - Microfiche Discrepancy
- Cooling Fan - Continuous Running/Dead Battery
- Cylinder Head Gasket - Revised
- Hand Brake Cable - Availability
- ABS System - Diagnostic Procedures
- ABS & TC/ABS System - Diode Locator and Fault Diagnosis
- ABS Tester - Description
- Brakes - ABS Wiring Harness Diodes Available
- Airbag - Component Replacement Update
- Airbag - Service Manual Correction
- Vehicle - Technical Tip Bulletin
- Supplementary Restraint System - 10 Year Inspection
- Restraints - Pyrotechnic Device Component Usage
- Alarm System - Installation Changes
- Alarm System - Microfiche Discrepancy
- Evaporative System - Leak/Pressure Testing
- ISAT Scan Tool Diagnostics Set - Changes
- Intelligent Saab Tester - Ordering Procedure
- Tools - ISAT TECH 2
- ISAT Scan Tool - Repair Procedure
- Tool - Modifying Pinion Bearing Fitting Ring Tool
- Convertible Top - Fabric Wear
- Windshield - Removal/Installation Procedures Revision
- Upper Center Windshield - Whistling Noise
- Wiper Blades - Care/Maintennance
- A/T - Idle Increase & Backup Light Malfunction
- A/T - Oil Cooling System Flushing
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Tools - Drift and Bearing Fitting Ring
- M/T - Recommended Gearbox Oil
- Gear Shift Lever - Microfiche Correction
- EGR Vacuum Hose Routing - Manual Revision
- Headlight Wiper Arms - Microfiche Correction
- Fog Lights - Applications/Part Numbers
- M/T Oil Drain Plug - Replacement
- Tool - New Test Cables for Breakout Box
- Wiring - Terminal Repair Kit Contents
- Engine - Hard Cold Weather Starting
- Convertible Top - Door Window Glass Slippage
- Convertible Top - New Adjustment Specification
- Convertible Top - Contacts Window Frame During Closing
- Convertible Top Soft Boot Cover - Availability
- Rubber Floor Mats - Availability
- Interior Trim - New Upholstery Material
- Underseat Waste Basket - Availability
- Paint - Codes/Cross References
- Paint - Codes & Crossreferences
- Paint - Codes
- Paint Codes - Applications and Cross Reference
- Engine - Poor Starting/Driveability Concerns
- Trailer Hitch Coupler - Insufficient Lubrication
- Trailer Hitch - Installation
- A/T Drive Gear - Microfiche Correction
- A/C - Refrigerant Recycling Equipment
- Seat Temperature Control Switch - Bulb Repair Kit
- Scheduled Maintenance - Labor Times
- Specialized Fluids, Lubricants and Supplies
- CD Changer - Manually Releasing a CD
- Frame - Lifting and Attachment Points
- Child Tether Anchorage - Availability
- A/C - Compressor Oil Recommendations
- Fuel System - TOP TIER Detergent Gasoline
- Body - Stain/Film On Inside Perimeter Of Windshield
- Wheels - Chrome Wheel Staining/Pitting/Corrosion