Canada - Suspension - Steering Wheel Flutter/Body Vibration

Bulletin
TSB3009

Issue Date
June 12, 2008

Market
Canada

Title
Steering Wheel Flutter/Body Vibration

Component
WHEELS & TIRES

Models
'07-'08 Avalon, Camry, Camry HV, & Solara

INTRODUCTION

Some 2007 - 2008 model year Avalon, Camry, Camry HV, and Solara vehicles may exhibit a steering wheel flutter and/or a body vibration (floor or seats) at highway speeds (approximately 105 - 121 km/h). This TSB includes diagnostic information, repair information, and updated parts information to address the customer's concern.

NOTE
Prior to determining if the suggested parts are necessary, verify that the vibration remains after confirming the appropriate diagnostic steps from the Suspension System Problem Symptoms Table (refer to the Repair Manual sections noted in step 3 of the Repair Procedure in this bulletin).






APPLICABLE VEHICLES:

PRODUCTION CHANGE INFORMATION:







This TSB applies to vehicles produced BEFORE the Production Change Effective VINs shown.


NOTE
- For Camry L4 and Camry V6 built at TMMK, the underlined number in the VIN (12th digit) represents plant assembly line code and is necessary to properly identify Production Change Effective VIN (0 - 4 = Line 1, 5 - 9 = Line 2).
- For Camry L4 built at SIA, the 3rd digit is "4" and the 10th digit is "R".
- The 9th digit of the VIN ("#") is used as a wild card (digit is not pertinent for applicability).






PARTS INFORMATION:






REQUIRED SSTS:

NOTE:
Additional SSTs may be ordered by calling SPX/OTC at 1-800-933-8335.






WARRANTY INFORMATION:

REPAIR PROCEDURE:

1. Visually check the tires and wheels, axle, and suspension for any concerns (damage, looseness, etc.).
2. Test drive the vehicle and confirm the customer's concern and vehicle condition.
3. Once the condition has been confirmed, refer to the applicable diagnostic steps below.
A. Identify the condition in the Problem Symptoms Table.

Refer to the Repair Manual within E-TAS / TIS library:
- Division: Toyota
- Model: Avalon / Camry / Camry HV / Solara
- Year: 2007 / 2008
- Service Category: Suspension
- Section: Rear Suspension
- Keyword: Suspension: Suspension System: Problem Symptoms Table

B. Proceed with troubleshooting.

Refer to the Repair Manual within E-TAS / TIS library:
- Division: Toyota
- Model: Avalon / Camry / Camry HV / Solara
- Year: 2007 / 2008
- Service Category: Suspension
- Section: Tire/Wheel
- Keyword: Tire and Wheel: Tire and Wheel System: How to Proceed with Troubleshooting

C. Inspect the tire.

Refer to the Repair Manual within E-TAS / TIS library:
- Division: Toyota
- Model: Avalon / Camry / Camry HV / Solara
- Year: 2007 / 2008
- Service Category: Suspension
- Section: Tire/Wheel
- Keyword: Tire and Wheel: Tire and Wheel System: Inspection

NOTE
- The specification for tire and wheel assembly uniformity for Radial Force Variation (RFV) = 60 N-m (13.5 ft-lbf).
- When performing a tire/wheel balance, the Haweka Flange Plate Kit, or an equivalent flange kit and the proper centering cone are required.

4. If the vibration condition remains after referring to the applicable diagnostics steps and/or repairs, then replace both front hub assemblies.

Refer to the Repair Manual within E-TAS / TIS library:
- Division: Toyota
- Model: Avalon / Camry / Camry HV / Solara
- Year: 2007 / 2008
- Service Category: Drivetrain
- Section: Axle/Differential
- Keyword: Axle: Front Axle Hub: Removal and Installation

5. Road test the vehicle to confirm that the vibration is NO longer present.

NOTE:
Issue of this Technical Service Bulletin is to ensure that proper repair information is available. IT DOES NOT CONSTITUTE AN AUTHORIZATION FOR REPAIR. Normal provisions of the formal warranty policy, as applicable, will apply.