Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 12V491000: Power Window Switch Overheating
- Recall - Accelerator Pedal Modification
- Recall 09V338000: Brake Booster Vacuum Connector Freezes
- Recall 10V017000: Accelerator Pedal Sticking
- Recall 10V023000: Accelerator Pedal Sticks Wide Open
- Recall - Power Window Master Switch Melting, Fires
- Dealer Letter
- Dealer Q and A
- Toyota Owner Letter - Interim
- Scion Owner Letter - Interim
- Toyota Owner Letter - Urgent Safety Recall
- Scion Owner Letter - Urgent Safety Recall
- Technical Instructions
- Information
- I. Operation Flow Chart
- I. Identification of Affected Vehicles
- II. Preparation
- III. Background
- IV. Components
- V. Preliminary Power Window Master Switch Operation Check
- VI. Power Window Master Switch Removal
- VII. Power Window Master Switch Inspection
- VIII. Grease Application
- IX. Switch Reassembly
- X. Power Window Master Switch Installation
- XI. Power Window Master Switch Operation Check
- XII. Appendix
- Customer Interest
- Body - Front Side Window Glass Rattling Noise When Operated
- Engine - MIL ON/DTC P0335 Set
- Canada - Glass - Upper/Lower Windshield Tick Noise
- Canada - Interior - Instrument Panel Rattle Noise
- Canada - Interior - front Seat Squeak Noise
- Canada - Engine Oil Consumption Repair
- Canada - Emissions - DTC's P043E/P043F/P2401/P2402/P2419
- Canada - Engine - Excessive Oil Consumption
- Canada - Interior - Driver's Seat Feels Loose
- Emissions - MIL ON/DTC's P043E/P043F/P2401/P2402/P2419
- Engine - Excessive Oil Consumption
- Fuel System - Extended High Altitude/Hot Crank Time
- Interior - Driver's Seat Feels Loose
- Engine, A/T Controls - Harsh Downshift When Stopping
- Cell Phone - Bluetooth(R) Call Volume Too Low/Distorted
- Engine Controls - MIL ON/Multiple DTC's Set
- Interior - Instrument Panel Rattling Noise
- Tire Monitor System - 'Lost Communication With ECU' Mssg
- Electrical - Multiple Lamp ON/No Shift From PARK
- Body - Wind Noise From Rear Of Vehicle
- Interior - Squeaking Noises From The Front Seat
- Interior - Condensation Dripping From The Dome Lamp
- Steering - Clunk/Pop Noise When Turning
- Starting System - Intermittent No Crank/No Start
- Interior - Glove Box Difficult To Close
- Body - Front Door Wind Noise Near The B-Pillar
- Body - Quarter Window Glass Bubbled/Scratched
- Paint - Staining Under Rapgard(R) Coating
- Interior - Lower B-Pillar Moulding Is Loose
- Audio - Satellite Radio Inoperative Until Key Is Cycled
- Engine Controls - MIL ON/DTC P0456 Set
- Body - Windshield/Back Glass Ticking Noise
- Body - Rear Hatch Won't Open Fully When Cold
- Canada - Interior - Condensation Dripping From The Dome Lamp
- Canada - Engine Controls - MIL ON/DTC P0456 Set
- Canada - Engine Controls - MIL ON/Multiple DTC's Set
- Canada - Engine, A/T Controls - Harsh Downshift When Stopping
- Canada - Steering - Clunk/Pop Noise When Turning
- Canada - Starting System - Intermittent No Crank/No Start - Col
- Canada - Starting System - Intermittent No Crank/No Start
- Canada - Electrical - Warning Lamp ON/No Shift From PARK
- Canada - Cell Phone - Bluetooth(R) Call Volume Too Low/Distorte
- Canada - Body - Wind Noise From Rear Of Vehicle
- Canada - Interior - Glove Box Difficult To Close
- Canada - Interior - Lower B-Pillar Moulding Is Loose
- Canada - Tire Monitor System - Lost Communication With ECU Mssg
- Canada - Body - Quarter Window Glass Bubbled/Scratched
- Canada - Body - Front Door Wind Noise Near The B-Pillar
- Canada - Engine - Int. MIL ON, DTC P0335 Set
- Brakes - Uneven Rear Brake Pad Wear
- Superceded Bulletins
- SC-C0M - 01/15/13
- SC-A0A - 02/05/10
- SB0042-08 - 04/21/08
- SB0100-09 - 03/31/09
- SU001-08 - 01/19/08
- Body - Windshield/Back Glass Ticking Noises
- Body - Ticking Noise From Windshield/Back Glass
- Recall - Power Window Master Switch Overheating/Melting
- Recall - Power Window Master Switch Replacement
- SC-COM-PRELIM - 10/10/12
- Body - Sealing Hem-Flanges And Body Seams
- Interior - Front Seat Squeaking Noises
- Body - Paint Stained Under Rapguard(R)
- Interior - B-Pillar Trim Is Loose
- Interior - Instrument Panel Rattle Noise
- Audio System - Satellite Radio Inop Until Ign. Is Cycled
- Restraints - Seat Belt Extender Information
- Electrical - Can't Shift A/T/Multiple Warning Lamps ON
- A/T - Remanufactured Transmission Serial Number Location
- A/T - Location Of Serial Numbers
- Recall - Accelerator Pedal Sticking
- Engine Controls - Techstream(R) ECU Re-Flash Procedure
- Engine - Serial Number Locations
- Tires - Inflation Pressure Compensation/Adjustment
- Engine - Oil Filter Cap Assembly Precautions
- Vehicle - Long Term Storage Information
- Tires - Pressure Compensation/Adjustment
- All Technical Service Bulletins
- Vehicle - Flood Damage Inspection And Handling
- Canada - Engine Controls - Accelerator Pedal Sensor Precaution
- Body - Front Side Window Glass Rattling Noise When Operated
- Engine - MIL ON/DTC P0335 Set
- Tires - Tire Repair Resources
- Recall 12V491000: Power Window Switch Overheating
- Body - Sealing Hem Flanges And Body Seams
- Canada - Glass - Upper/Lower Windshield Tick Noise
- Canada - Interior - Instrument Panel Rattle Noise
- Canada - Interior - front Seat Squeak Noise
- Canada - A/T - A/T Serial Number Location
- Canada - A/T - Installation Precautions
- Canada - Body - Front Fender Liner Pin Hold Clip
- Canada - Alignment - Zero Point Calibration On VSC
- Canada - Tire Monitoring System - TPMS Initialization
- Canada - Instruments - Initial Calibration Of Compass
- Fuel System - Accelerator Pedal Sensor Service Precaution
- Canada - Engine Oil Consumption Repair
- Canada - Emissions - DTC's P043E/P043F/P2401/P2402/P2419
- Canada - Restraints - Seat Cover Replacement On Side Air Bag
- Canada - Suspension - Shock Absorber Replacement Criteria
- Canada - Electrical - Interior Electrical Component Precautions
- Canada - Cooling System - Water Pump Leak Inspection/Diagnostic
- Canada - Engine - Excessive Oil Consumption
- Canada - Interior - Driver's Seat Feels Loose
- Canada - A/T - Torque Converter Bolt Installation Precautions
- Canada - A/T - World Standard Automatic Transmission Fluid
- Body - Welding Specifications & Substitutions
- Emissions - MIL ON/DTC's P043E/P043F/P2401/P2402/P2419
- Body - Collision Repair Information
- Suspension - Shock Absorber Replacement Criteria
- Restraints - Seat Cover Replacement On Side Air Bag Veh.
- Cooling System - Water Pump Leak Inspection/Diagnostics
- Electrical - Interior Electrical Component Precautions
- Engine - Excessive Oil Consumption
- A/T - Replacement Precautions
- Fuel System - Extended High Altitude/Hot Crank Time
- Interior - Driver's Seat Feels Loose
- Recall - Accelerator Pedal Modification
- A/T - Torque Converter Bolt Installation Precautions
- A/T - World Standard Automatic Transmission Fluid
- Vehicle - Usage Of Non-OE Parts
- Vehicle - VIN Plate/Certification Label Replacement
- Vehicle - Certification Label Information
- Body - Paintless Dent Repair Information
- Engine - Cylinder Head Cover Baffle Precautions
- ABS/TCS - Zero Point Calibration Information
- A/T, M/T - Alignment Pin Service Precaution
- Instruments - Compass Calibration Procedure
- Body/Frame - Protective Wax Coating Information
- Tire Monitor System - Initialization Procedure
- Steering/Suspension - Vehicle Pull Repair Supplement
- Engine, A/T Controls - Harsh Downshift When Stopping
- Cell Phone - Bluetooth(R) Call Volume Too Low/Distorted
- Body/Frame - Sectioning Information
- Body - Panel Adhesive Information
- Body - Collision Damage Repair Precautions
- Body - Acid Rain Paint Damage Prevention/Repair
- Body/Interior - Trim Removal And Installation
- Restraints - SRS Service Precautions
- Engine Controls - MIL ON/Multiple DTC's Set
- Interior - Instrument Panel Rattling Noise
- Interior - Sun Visor Removal/Installation Procedure
- Tire Monitor System - 'Lost Communication With ECU' Mssg
- Body - Plastic Bumper Refinishing
- Body - Bumper Component Repair
- Electrical - Multiple Lamp ON/No Shift From PARK
- Restraints - Proper Rear Seat Belt Orientation
- Body - Wind Noise From Rear Of Vehicle
- Paint - Refinishing Information
- Interior - Squeaking Noises From The Front Seat
- Restraints - Seat Belt Extender Info.
- Engine - Serial Number Locations/Identification
- Interior - Condensation Dripping From The Dome Lamp
- Steering - Clunk/Pop Noise When Turning
- Starting System - Intermittent No Crank/No Start
- Electrical - SRS And HV Wiring Repairs
- Interior - Glove Box Difficult To Close
- Recall 09V338000: Brake Booster Vacuum Connector Freezes
- A/T - Serial Number Identification/Locations
- A/T - Reman A/T Serial Number Identification/Locations
- Body - Front Door Wind Noise Near The B-Pillar
- Vehicle - Long Term Storage Guidelines
- Drivetrain - 4WD Towing Precautions
- Tires - Pressure Compensation And Adjustment
- Recall 10V017000: Accelerator Pedal Sticking
- Recall 10V023000: Accelerator Pedal Sticks Wide Open
- Body - Quarter Window Glass Bubbled/Scratched
- Paint - Staining Under Rapgard(R) Coating
- Interior - Lower B-Pillar Moulding Is Loose
- Audio - Satellite Radio Inoperative Until Key Is Cycled
- Interior - Floor Mat Installation/Precautions
- Remote Starting System - Cold Weather Starting Tips
- Engine Controls - MIL ON/DTC P0456 Set
- Fuel System - Throttle Body Update
- Body - Windshield/Back Glass Ticking Noise
- Body - Corrosion Prevention And Sound Absorption Info.
- Body - HSS/UHSS Cabin Reinforcement Repair/Replacement
- Body - Approved Collision Repair Methods
- Restraints - OCS System Initialization
- Body - Rear Hatch Won't Open Fully When Cold
- Canada - Steering/Suspension - Vehicle Pull Repair Supplement
- Canada - Drivetrain - 4WD Towing Precautions
- Canada - Engine - Cylinder Head Cover Baffle Precautions
- Canada - Interior - Condensation Dripping From The Dome Lamp
- Canada - Engine Controls - MIL ON/DTC P0456 Set
- Canada - Engine Controls - MIL ON/Multiple DTC's Set
- Canada - Engine, A/T Controls - Harsh Downshift When Stopping
- Canada - Steering - Clunk/Pop Noise When Turning
- Canada - Starting System - Intermittent No Crank/No Start - Col
- Canada - Starting System - Intermittent No Crank/No Start
- Canada - Fuel System - Throttle Body Update
- Canada - Electrical - Warning Lamp ON/No Shift From PARK
- Canada - Cell Phone - Bluetooth(R) Call Volume Too Low/Distorte
- Canada - Restraints - Proper Rear Seat Belt Orientation
- Canada - Body - Wind Noise From Rear Of Vehicle
- Canada - Interior - Glove Box Difficult To Close
- Canada - Interior - Lower B-Pillar Moulding Is Loose
- Canada - Interior - Floor Mat Installation/Precautions
- Canada - Interior - Sun Visor Removal/Installation Procedure
- Canada - Tire Monitor System - Lost Communication With ECU Mssg
- Canada - Body - Quarter Window Glass Bubbled/Scratched
- Canada - Body - Front Door Wind Noise Near The B-Pillar
- Canada - Engine - Int. MIL ON, DTC P0335 Set
- Computers/Controls - Techstream(R) Reprogramming Procedure
- Brakes - Uneven Rear Brake Pad Wear
- Recall - Power Window Master Switch Melting, Fires
- Dealer Letter
- Dealer Q and A
- Toyota Owner Letter - Interim
- Scion Owner Letter - Interim
- Toyota Owner Letter - Urgent Safety Recall
- Scion Owner Letter - Urgent Safety Recall
- Technical Instructions
- Information
- I. Operation Flow Chart
- I. Identification of Affected Vehicles
- II. Preparation
- III. Background
- IV. Components
- V. Preliminary Power Window Master Switch Operation Check
- VI. Power Window Master Switch Removal
- VII. Power Window Master Switch Inspection
- VIII. Grease Application
- IX. Switch Reassembly
- X. Power Window Master Switch Installation
- XI. Power Window Master Switch Operation Check
- XII. Appendix
- Body/Frame - Body Sectioning Information
- Emissions - CA/FED Emissions Underhood Label Ordering