Operation CHARM: Car repair manuals for everyone.

972419 Removing and Installing Wire Harness For Removable Trailer Hitch


WM 972419 Removing and installing wire harness for removable trailer hitch

Preliminary work

1. Remove rear right luggage compartment side-panel lining. -> 700319 Removing and installing side-panel lining for rear luggage compartment - section on "Removing" 700319 Removing and installing rear luggage compartment side-trim panel
2. Remove loudspeaker amplifier. -> 914419 Removing and installing loudspeaker amplifier - section on "Removing" Service and Repair
3. Remove CD changer with holder. -> 916019 Removing and installing CD changer - section on "Removing" Service and Repair

Removing wiring harness for removable trailer hitch





Overview of wiring harness for removable trailer hitch

1. Release the connector -arrow A- and pull it off -arrow B-.





Pulling off connector

2. Cut the tie-wraps -arrows-.





Cutting tie-wraps

3. Press out the rubber sleeve -a- from the inside and pull the lead out through the opening -arrow-.





Removing wiring

4. Cut the tie-wraps -b-.
5. Open up the cover -arrow A- , unscrew the fastening screws -arrows 1- and remove the socket.





Removing socket

6. Take the rubber sleeve -arrow C- out of the bracket.
7. Release the plate -arrows B- and pull it - together with the rubber seal -d- - out of the contact housing -e- ( -arrow C- ).
8. Push the rubber sleeve and contact housing up through the fastening flange -arrow- and remove the lead.





Removing lead (2)

Installing wiring harness for removable trailer hitch

1. Pull the connector and rubber sleeve down through the fastening flange -arrow-.





Installing lead (2)

2. Position the leads with new tie-wraps -b- , but do not tighten.





Positioning and securing lead

3. Connect the carrier to the contact housing -e- ( -arrow A- ) until the locking tabs are felt to engage -arrows B-.





Installing socket

4. Insert the carrier with the contact housing -e- into the socket.
5. Position the rubber sleeve -c- on the socket.
6. Position the socket with the rubber sleeve in installation position, then open up the socket -arrow C- and secure to the holder with the fastening screws -arrows 1-.
7. Push the lead in -arrow- and press the rubber sleeve -a- in until it engages audibly.





Installing lead

8. Fasten the tie-wraps -b-.
9. Insert the connector -arrow A- until the locking tab -B- is felt to engage.





Inserting the connector

10. Secure the lead with new tie-wraps -arrows-.





Securing lead with new tie-wraps

Subsequent work

1. Install CD changer with holder. -> 916019 Removing and installing CD changer - section on "Installing" Service and Repair
2. Install loudspeaker amplifier. -> 914419 Removing and installing loudspeaker amplifier - section on "Installing" Service and Repair
3. Install rear right luggage compartment side-panel lining. -> 700319 Removing and installing side-panel lining for rear luggage compartment - section on "Installing" 700319 Removing and installing rear luggage compartment side-trim panel